电子器件散热串联轴流风扇短管降噪试验

doi:10.3901/JME.2022.22.406

机械工程学报 ›› 2022, Vol. 58 ›› Issue (22): 406-415.doi: 10.3901/JME.2022.22.406

• 可再生能源与工程热物理 • 上一篇下一篇

扫码分享

电子器件散热串联轴流风扇短管降噪试验

孙宗翰¹, 田杰^1,2, 杜朝辉¹, 欧阳华^1,2

1. 上海交通大学机械与动力工程学院上海 200240;
2. 燃气轮机与民用航空发动机教育部工程研究中心上海 201306

收稿日期:2021-12-03 修回日期:2022-04-25 出版日期:2022-11-20 发布日期:2023-02-07
通讯作者: 欧阳华(通信作者),男,1973年出生,研究员,博士研究生导师。主要研究方向为航空发动机不稳定流动及气动声学、风扇/压气机内部流动试验与数值模拟等。E-mail:oyh@sjtu.edu.cn
作者简介:孙宗翰,男,1995年出生,博士研究生。主要研究方向为叶轮机械气动声学。E-mail:szhdjaccount@sjtu.edu.cn
基金资助:
航空发动机及燃气轮机重大专项基础研究项目(J2019-II-0013-0034)

Experimental Study on Aerodynamic Noise Reduction of In-series Axial Cooling Fans for Electronic Devices

SUN Zong-han¹, TIAN Jie^1,2, DU Chao-hui¹, OUYANG Hua^1,2

1. School of Mechanical Engineering, Shanghai Jiao Tong University, Shanghai 200240;
2. Engineering Research Center of Gas Turbine and Civil Aero Engine of Ministry of Education, Shanghai 201306

Received:2021-12-03 Revised:2022-04-25 Online:2022-11-20 Published:2023-02-07

摘要/Abstract

摘要： 对两台电子器件散热轴流风扇采用不同方式串联时的气动噪声特性开展试验研究。首先利用风扇等高平面内环形布置的传声器阵列对单风扇和串联风扇的远场噪声进行测量,发现串联风扇相比单风扇具有更高的宽频噪声和更复杂的单音噪声特性。然后对比加装方框、蜂窝和短管中间连接件的串联风扇在不同转速下的噪声声压级指向性分布,发现短管连接件对串联风扇的单音和宽频噪声均具有良好的降噪效果,其中设计转速下单音相比方框连接的串联风扇下降1.2dB(A),宽频下降0.5dB(A)。最后,提出串联风扇的两段短管降噪方法并验证了其在多转速运行工况下的降噪效果。论文对串联电子器件散热风扇气动噪声的研究可为工程应用中的降噪措施提供参考。

关键词: 串联散热风扇, 降噪, 声指向性, 噪声成分分析

Abstract: An experimental study on the aerodynamic noise characteristics of two electronic device axial flow cooling fans connected in series in different ways is carried out. First, the far-field noise of a single fan and fans in series is measured by a microphone array arranged in a ring in the contour plane of the fan. It is found that fans in series had higher broadband noise and more complex tonal noise than the single fan. Then the directivity of the sound pressure level of fans in series with middle connectors of the square,honeycomb and short duct at different rotational speeds is compared. The connector of short duct had a good noise reduction effect on the tonal and broadband noise of fans in series, in which the tonal noise decreased 1.2 dB(A) and the broadband noise decreased 0.5dB(A) compared with the square connected fans at the rated speed. Finally, the noise reduction method of two-stage short duct for fans in series is proposed and its noise reduction effect at multi-speed is verified. The research on the aerodynamic noise of axial flow cooling fans in series can provide reference for the noise reduction measures in the engineering application.

Key words: cooling fans in series, noise reduction, directivity, noise component analysis

中图分类号:

TH42

孙宗翰, 田杰, 杜朝辉, 欧阳华. 电子器件散热串联轴流风扇短管降噪试验[J]. 机械工程学报, 2022, 58(22): 406-415.

SUN Zong-han, TIAN Jie, DU Chao-hui, OUYANG Hua. Experimental Study on Aerodynamic Noise Reduction of In-series Axial Cooling Fans for Electronic Devices[J]. Journal of Mechanical Engineering, 2022, 58(22): 406-415.

参考文献

[1] HUANG Lixi. Characterizing computer cooling fan noise[J]. Journal of the Acoustical Society of America,2003,114(6):3189-3200.
[2] CAROLUS T. Ventilatoren-Aerodynamischer entwurf,schallvorhersage,konstruktion[M]. Wiesbaden:Vieweg+Teubner Verlag,2013.CAROLUS T. Fans-Aerodynamic design, sound prediction,construction[M]. Wiesbaden:Vieweg+Teubner Press,2013.
[3] BLAKE W K. Mechanics of flow-induced sound and vibration,Volume 1:General concepts and elementary sources[M]. New York:Academic Press,1986.
[4] BOMMES L, FRICKE J, GRUNDMANN R.Ventilatoren[M]. Essen:Vulkan-Verlag,2003.BOMMES L,FRICKE J,GRUNDMANN R. Fans[M].Essen:Vulkan Press,2003.
[5] WAGNER S,BAREIßR,GUIDATI G. Wind turbine noise[M]. Berlin:Springer,1996.
[6] BROOKS T F,POPE S D,MARCOLINI M A. Airfoil self-noise and prediction[M]. Washington D.C.:NASA Reference Publication 1218,1989.
[7] BLAKE W K. Mechanics of flow-induced sound and vibration, Volume 2:Complex flow-structure interactions[M]. New York:Academic Press,1986.
[8] MOREAU D J,DOOLAN C J,ALEXANDER W N,et al. Wall-mounted finite airfoil-noise production and prediction[J]. AIAA Journal,2016,54(5):1637-1651.
[9] GIEZ J,VION L,ROGER M,et al. Effect of the edge-and-tip vortex on airfoil selfnoise and turbulence impingement noise[C]//22nd AIAA/CEAS Aeroacoustics Conference. 2016:2996.
[10] GUTIN L. On the sound field of a rotating propeller[J].NACA,1948:TM-1195.
[11] TYLER J M,SOFRIN T G. Axial flow compressor noise studies[J]. Transaction of the Society of Automotive Engineers,1962,70:309-332.
[12] WRIGHT S E. The acoustic spectrum of axial flow machines[J]. Journal of Sound and Vibration,1976,45(2):165-223.
[13] WRIGHT T,SIMMONS W E. Blade sweep for low-speed axial fans[J]. Journal of Turbomachinery,1990,112(1):151-158.
[14] TIAN Jie,SUN Zonghan,CHAI Pengfei,et al. Study on the influence of inlet asymmetry on aerodynamic noise of cooling fan[J]. Journal of Engineering for Gas Turbines and Power,2020,142(12):121014.
[15] 孙宗翰,田杰,郑浩轩,等.电子器件轴流冷却风扇气动噪声周向模态试验[J].机械工程学报,2020,56(18):164-171.SUN Zonghan,TIAN Jie,ZHENG Haoxuan,et al.Azimuthal mode experiment of aerodynamic noise of axial flow fan for electronic device heat dissipation[J].Journal of Mechanical Engineering, 2020, 56(18):164-171.
[16] SUN Zonghan,TIAN Jie,LIŚKIEWICZ G,et al. Noise reduction analysis of electronic device cooling fan with duct and its application under variable working conditions[J]. Journal of Engineering for Gas Turbines and Power,2022,144(2):021008.
[17] FITZGERALD J M, LAUCHLE G C. Reduction of discrete frequency noise in small,subsonic axial-flow fans[J]. Journal of the Acoustical Society of America,1984,76(1):158-166.
[18] WANG Jian,HUANG Lixi. Quantification and control of noise sources in a small axial-flow fan[J]. Noise Control Engineering Journal,2006,54(1):27-32.
[19] LIU Naitong,JIANG Changyong,HUANG Lixi,et al.Effect of porous casing on small axial-flow fan noise[J].Applied Acoustics,2021,175:107808.
[20] WANG Chen,ZHANG Weihao,HUANG Lixi. Noise source analysis and control of two axial-flow cooling fans in series[J]. Noise Control Engineering Journal,2016,64(5):677-687.
[21] WANG Chen,HUANG Lixi. Acoustic analysis of two small axial-flow fans in series[J]. Noise Control Engineering Journal,2017,65(4):320-335.
[22] WANG Chen. Noise source analysis for two identical small axial-flow fans in series under operating condition[J]. Applied Acoustics,2018,129:13-26.
[23] 李波,王虎.轴流风扇串联特性研究[J].电子机械工程,2013,29(5):16-20,33.LI Bo,WANG Hu. Study on performance of fans in series[J]. Electro-Mechanical Engineering,2013,29(5):16-20,33.
[24] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会. GB/T 2888-2008风机和罗茨鼓风机噪声测量方法[S].北京:中国标准出版社,2008.General Administration of Quality Supervision,Inspection and Quarantine of the People's Republic of China,Standardization Administration of the People's Republic of China. GB/T 2888-2008 Methods of noise measurement for fans blowers compressors and Roots blowers[S]. Beijing:Standards Press of China,2008.

电子器件散热串联轴流风扇短管降噪试验

Experimental Study on Aerodynamic Noise Reduction of In-series Axial Cooling Fans for Electronic Devices

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王志颖, 李天福, 许文纲, 孙闯, 张军辉, 徐兵, 严如强. 降噪混合注意力变分自编码器及其在轴向柱塞泵故障诊断中的应用[J]. 机械工程学报, 2024, 60(4): 167-177.
[2]	孙梦楠, 董祉序, 徐威, 孙兴伟, 刘伟军. 基于改进低秩稀疏分解的光斑图像降噪方法研究[J]. 机械工程学报, 2024, 60(2): 17-26.
[3]	张金娈, 邓祖强, 张鑫, 王亮. 基于深度学习SDAE-BP的暂降类型识别方法^*[J]. 电气工程学报, 2022, 17(3): 184-193.
[4]	葛帅, 成功, 圣小珍, 史佳伟. 旋转对阻尼车轮降噪效果的影响分析[J]. 机械工程学报, 2021, 57(4): 164-173.
[5]	孙凤山, 范孟豹, 曹丙花, 叶波, 刘林. 基于几何纹理与Anscombe变换的蜂窝材料太赫兹图像降噪模型[J]. 机械工程学报, 2021, 57(22): 96-105.
[6]	陶功权, 谢清林, 刘晓龙, 任德祥, 温泽峰. 形态学滤波方法在车轮非圆化信号降噪中的应用[J]. 机械工程学报, 2020, 56(18): 116-122.
[7]	陈文卿, 沈九兵, 严思远, 刘华, 周明龙. 半封闭变频螺杆制冷压缩机降噪方法及试验[J]. 机械工程学报, 2020, 56(14): 188-195.
[8]	董鑫, 李国龙, 何坤, 贾亚超, 徐凯, 李彪. 谱图小波阈值降噪及其在滚刀主轴振动信号分析中的应用[J]. 机械工程学报, 2020, 56(11): 96-107.
[9]	胡超凡, 王衍学. 基于张量分解的滚动轴承复合故障多通道信号降噪方法研究[J]. 机械工程学报, 2019, 55(12): 50-57.
[10]	侯文擎, 叶鸣, 李巍华. 基于改进堆叠降噪自编码的滚动轴承故障分类[J]. 机械工程学报, 2018, 54(7): 87-96.
[11]	张亚东, 韩璐, 李明, 张继业. 高速列车受电弓气动噪声降噪^*[J]. 机械工程学报, 2017, 53(6): 94-101.
[12]	鲍晓华,李佳庆,魏琼,杨帆,唐奎. 爪极发电机转子磁极间铜焊降低电磁激振力波研究[J]. 电气工程学报, 2016, 11(6): 1-8.
[13]	周邵萍, 张蒲根, 吕文超, 郝占峰. 基于导波的弯管裂纹缺陷的检测[J]. 机械工程学报, 2015, 51(6): 58-65.
[14]	曾鸣, 杨宇, 郑近德, 程军圣. u-SVD降噪算法及其在齿轮故障诊断中的应用[J]. 机械工程学报, 2015, 51(3): 95-103.
[15]	汪久根;陈仕洪. Koch雪花表面织构设计与高铁空气摩擦噪声分析[J]. , 2014, 50(7): 78-83.