共振型液压脉动衰减器研究现状及展望

doi:10.3901/JME.2015.22.168

摘要/Abstract

摘要： 压力脉动通常被认为是振动和噪声的主要来源，使用合适的方法衰减压力脉动对液压系统的减振降噪有着十分重要的意义。共振型液压脉动衰减器由于能够有效衰减固有频率附近的压力脉动、压力损失小、变换类型多、成本低、可靠性高，在实际中得到了广泛的运用。在归纳总结国内外研究现状的基础上，将共振型脉动衰减器分为H型、多腔体型、流体-结构耦合振动型三类，并分别阐述各个类别的研究进展及使用性能。对各个类别的共振型脉动衰减器性能特点进行比较以方便用户合理选用设计。针对现存技术存在的不足，阐述今后研究的重点方向并指出紧凑性好、通用性高、频率适应性强是未来共振型液压脉动衰减器的发展趋势。提出一种新型拓扑结构的共振型脉动衰减器，该种衰减器能够灵活调整自身形状以适应严苛的安装空间要求。

关键词: 共振型, 脉动衰减器, 液压系统

Abstract: Pressure pulsation is generally considered as the main source of vibration and noise, attenuating the pressure pulsation in an appropriate method has a very important significance for reducing vibration and noise in the hydraulic system. Due to the effectiveness in attenuating the pressure pulsation near the nature frequency, small pressure loss, conversion of many kinds, low cost and high reliability, resonant-type hydraulic pulsation attenuators have been widely used in practice. After summarizing the research status, the resonant-type hydraulic pulsation attenuators are classified into three categories：Helmholtz resonator, multiple-chamber type and fluid-structure coupled vibration type, research progress and performance of each category are expounded respectively. Comparisons are conducted among the performance characteristics of each category resonance-type pulsation attenuator to facilitate the users to chose and design them properly. For the deficiency of current technology, the focus direction of the further research is elaborated and it is concluded that good compactness, nice versatility, excellent adaptability of attenuation frequency is the future trend of development of resonant-type hydraulic pulsation attenuator. Finally, a resonant-type pulsation attenuator of new topology structure is proposed, this kind of attenuator can flexibly adjust its shape to fit the demanding space requirements.

Key words: hydraulic system, pulsation attenuator, resonant-type

欧阳小平, 李磊, 方旭, 杨华勇. 共振型液压脉动衰减器研究现状及展望[J]. 机械工程学报, doi: 10.3901/JME.2015.22.168.

OUYANG Xiaoping, LI Lei, FANG Xu, YANG Huayong. Research Status and Prospects of Resonant-type Hydraulic Pulsation Attenuators[J]. Journal of Mechanical Engineering, doi: 10.3901/JME.2015.22.168.

参考文献

[1] KOJIMA E，ICHIYANAGI T. Research on pulsation attenuation characteristics of silencers in practical fluid power systems[J]. International Journal of Fluid Power，2000，1(2)：29-38.
[2] 蔡亦钢. 流体传输管道动力学[M]. 杭州：浙江大学出版社，1990. CAI Yigang. Dynamics of fluid transfer pipeline[M]. Hangzhou：Zhejiang University Press，1990.
[3] HARRISON K A，EDGE K A. Reduction of axial piston pump pressure ripple[J]. Proceedings of the Institution of Mechanical Engineers，Part I：Journal of Systems and Control Engineering，2000，214(1)：53-64.
[4] 王占林．飞机高压液压能源系统[M]. 北京：北京航空航天大学出版社，2004. WANG Zhanlin. Aircraft high pressure hydraulic energy systems[M]. Beijing：Beihang University Press，2004.
[5] KWONG A H M，EDGE K A. A method to reduce noise in hydraulic systems by optimizing pipe clamp locations[J]. Proceedings of the Institution of Mechanical Engineers，Part I：Journal of Systems and Control Engineering，1998，212(4)：267-280.
[6] 高锋. 飞机液压系统泵—管路振动特性研究[D]. 杭州：浙江大学，2013.
GAO Feng. Investigation into the vibration characteristic of the pump and connected pipeline in the aircraft hydraulic system[D]. Hangzhou：Zhejiang University，2012.
[7] 曾祥荣. 液压噪声控制[M]. 哈尔滨：哈尔滨工业大学出版社，1988. ZENG Xiangrong. Hydraulic noise control[M]. Harbin：Harbin Institute of Technology Press，1988.
[8] KELA L. Resonant frequency of an adjustable Helmholtz resonator in a hydraulic system[J]. Archive of Applied Mechanics，2009，79(12)：1115-1125.
[9] de BEDOUT J M，FRANCHEK M A，BERNHARD R J，et al. Adaptive-passive noise control with self-tuning Helmholtz resonators[J]. Journal of Sound and Vibration，1997，202(1)：109-123.
[10] SELAMET A，RADAVICH P M，DICKEY N S，et al. Circular concentric Helmholtz resonators[J]. The Journal of the Acoustical Society of America，1997，101(1)：41-51.
[11] EARNHART N E，CUNEFARE K A. Compact Helmholtz resonators for hydraulic systems[J]. International Journal of Fluid Power，2012，13(1)：1-50.
[12] MUNJAL M L. Acoustics of ducts and mufflers[M]. Chichester：John Wiley & Sons，2014.
[13] SELAMET A，JI Z L. Circular asymmetric Helmholtz resonators[J]. The Journal of the Acoustical Society of America，2000，107(5)：2360-2369．
[14] DICKEY N S，SELAMET A. Helmholtz resonators：One-dimensional limit for small cavity length-to-diameter ratios[J]. Journal of sound and vibration，1996，195(3)：512-517.
[15] SELAMET A，LEE I. Helmholtz resonator with extended neck[J]. The Journal of the Acoustical Society of America，2003，113(4)：1975-1985.
[16] 杜润. 液压系统脉动衰减器的特性分析[D]. 成都：西南交通大学，2010.
DU Run. The characteristic analysis of pulsation dampers in hydraulic systems[D]. Chengdu：Southwest Jiaotong University，2010.
[17] KELA L，V?H?OJA P. Control of an adjustable Helmholtz resonator in a low-pressure hydraulic system[J]. International Journal of Fluid Power，2009，10(3)：29-39.
[18] KOJIMA E，ICHIYANAGI T. Development research of new types of multiple volume resonators[C]//Bath Workshop on Power Transmission and Motion Control，University of Bath，UK，1998：193-206.
[19] GUAN Changbin，JIAO Zongxiao. Modeling and optimal design of 3 degrees of freedom Helmholtz resonator in hydraulic system[J]. Chinese Journal of Aeronautics，2012，25：776-783.
[20] 曾祥荣，张建成. 多孔同心式液压消声器的研究[J]. 机床与液压，1990(3)：41-43.ZENG Xiangrong，ZHANG Jiancheng. Study of porous concentric hydraulic silencer[J]. Machine Tool and Hydraulics，1990(3)：41-43.
[21] 章寅. 液压系统脉动衰减器特性研究[D]. 杭州：浙江大学，2011. ZHANG Yin. The Performances of the pressure pulsation attenuator in hydraulic systems[D]. Hangzhou：Zhejiang University，2011.
[22] MIKOTA J，REITER H. Development of a compact and tuneable vibration compensator for hydraulic systems[J]. International Journal of Fluid Power，2003，4(1)：17-31.
[23] GAO Feng，OUYANG Xiaoping，YANG Huayong，et al. A novel pulsation attenuator for aircraft piston pump[J]. Mechatronics，2013，23(6)：566-572.
[24] 王守兵. 柔性膜片式流体滤波器的研究[D]. 长沙：长沙理工大学，2012. WANG Shoubing. Research on the membrane fluid pulsation attenuator[D]. Changsha：Changsha University of Science & Technology，2012.
[25] 贺尚红, 王雪芝, 何志勇, 等. 薄板振动式液压脉动衰减器滤波特性[J]. 机械工程学报，2013，49(4)；148-153.HE Shanghong，WANG Xuezhi，HE Zhiyong，et al. Filtering properties of thin plate hydraulic pulsation attenuator[J]. Journal of Mechanical Engineering，2013，49(4)：148-153.
[26] 贺尚红，桑青青，贺华波，等. 基于机械吸振原理的多自由度薄板振动式脉动衰减器滤波特性[J]. 中南大学学报，2014，45(5)：1457-1462.HE Shanghong，SANG Qingqing，HE Huabo，et al. Filtering properties of fluid pulsation attenuator with multiple thin plate based on absorbing principle of mechanical vibration[J]. Journal of Central South University，2014，45(5)：1457-1462.
[27] GARBACIK A，SZEWCZYK K. New aspects of modelling of fluid power control[M]. Wroclaw：Ossolineum，1995.
[28] 赵克定，李尚义，罗晓鸣，等. 并联和串联囊式蓄能器的理论分析和数字仿真[J]. 哈尔滨工业大学学报，1991，2(4)：66-74. ZHAO Keding，LI Shangyi，LUO Xiaoming，et al. Theoretical analysis and digital simulation of series and parallel bladder accumulator[J]. Journal of Harbin Institute of Technology，1991，2(4)：66-74.
[29] 邢科礼，葛思华. 新型串联囊式蓄能器对油源压力脉动影响的试验研究[J]. 机床与液压，1998(1)：39-40. XING Keli，GE Sihua. Experimental study of the effect of new-type series bladder accumulator on pressure pulsation of oil source[J]. Machine Tool and Hydraulics 1998(1)：39-40.
[30] SHIERY J C. Noise suppressor：US，5732741[P]. 1998-3-31.
[31] Wikers&Mclean. Hydraulic noise，shock，vibration and pulsation[EB/OL].[2010-04-18].http://www.wilkesandmclean.com/Suppressor5-20.pdf.
[32] MAREK K A，GRUBER E R，CUNEFARE K A. Linear multimodal model for a pressurized gas bladder style hydraulic noise suppressor[J]. International Journal of Fluid Power，2013，14(2)：5-16.
[33] GRUBER E R，CUNEFARE K A，DANZL P W，et al. Optimization of single and dual suppressors under varying load and pressure conditions[J]. International Journal of Fluid Power，2013，14(3)：27-34.
[34] KOJIMA E，EDGE K A. Experimental determination of hydraulic silencer transfer matrices and assessment of the method for use as a standard test procedure[C/CD]// Innovations in Fluid Power：7th Bath International Fluid Power Workshop. University of Bath，1994.
[35] LAU K K，EDGE K A，JOHNSTON D N. Fluid borne noise characteristics of hydraulic filters and silencers[C/CD]//Innovations in Fluid Power: 7th Bath International Fluid Power Workshop. University of Bath, 1994.
[36] IJAS M. Damping of low frequency pressure oscillation[D]. Tampere：Tampere University of Technology，2007.
[37] 欧阳小平，李磊，方旭，等. 集成在柱塞泵壳体内的多自由度可调节压力脉动衰减器：中国，201410259805.8 [P]. 2014-09-10. OUYANG Xiaoping，LI Lei，FANG Xu，et al. Multiple degrees of freedom adjustable pressure pulsation attenuator integrated in an piston pump case：China，201410259805.8[P]. 2014-09-10.