超声多普勒谱修正的油水两相流流速测量

doi:10.3901/JME.2017.24.077

机械工程学报 ›› 2017, Vol. 53 ›› Issue (24): 77-84.doi: 10.3901/JME.2017.24.077

• 多相流测试新技术与新方法 • 上一篇下一篇

扫码分享

超声多普勒谱修正的油水两相流流速测量

史雪薇^1,2, 谭超^1,2, 董虓霄^1,2, 董峰^1,2

1. 天津大学天津市过程检测与控制重点实验室天津 300072;
2. 天津大学电气自动化与信息工程学院天津 300072

收稿日期:2016-12-12 修回日期:2017-08-08 发布日期:2017-12-20
通讯作者: 谭超(通信作者),男,1980年出生,博士,副教授,博士研究生导师。主要研究方向为多传感器融合技术、多相流测试与信息处理。E-mail:tanchao@tju.edu.cn
作者简介:史雪薇,女,1992年出生。主要研究方向为多相流测试与信息处理。E-mail:sxw0230@tju.edu.cn
基金资助:
国家自然科学基金资助项目（61473206，61227006）。

Oil-water Two-phase Flow Velocity Measurement Based on Ultrasonic Doppler Spectrum Correction

SHI Xuewei^1,2, TAN Chao^1,2, DONG Xiaoxiao^1,2, DONG Feng^1,2

1. Tianjin Key Laboratory of Process Measurement and Control, Tianjin University, Tianjin 300072;
2. School of Electrical and Information Engineering, Tianjin University, Tianjin 300072

Received:2016-12-12 Revised:2017-08-08 Published:2017-12-20

摘要/Abstract

摘要： 针对水平管道油水两相流流速的无扰动测量问题，提出一种基于超声/电学双模态传感器的流速测量方法。测量系统由连续波超声多普勒传感器和基于电容与电导的电学传感器构成，分别用于获取两相流流速和分相含率。由于连续波多普勒的测量区域集中于管道中心，受流速剖面、含率分布影响，所测得流速并非流体的总表观流速。在假设含率分布满足高斯分布的前提下，建立相含率加权的多普勒能量谱模型，将含率分布的影响因素引入总表观流速的测量，并建立总表管流速和分相表观流速的计算模型。在试验基础上，分别确定水连续和油连续时总表观流速计算模型的参数。试验表明，通过模型计算出的表观流速与实际测量的流速能够较好吻合，总表观流速的相对误差小于6.32%，分相表观流速的方均根误差小于5.64%。

关键词: 超声波多普勒, 电容与电导, 流速测量, 双模态, 油水两相流

Abstract: For the overall superficial velocity non-disturbance measurement of oil-water two-phase flow in horizontal pipeline, a measurement method based on dual-mode of ultrasonic and electrical is proposed. A system combined continuous-wave ultrasonic Doppler sensors and conductance/capacitance sensors is used to estimate the velocity and holdup of two phase flow. Because the continuous-wave ultrasonic Doppler measurement region is concentrated in the pipe center, the holdup distribution and the velocity profile will lead to the difference between flow velocity obtained by Doppler shift and the overall superficial velocity. On the assumption that the holdup distribution satisfies Gauss distribution, establish the modified Doppler power spectrum model. The influence of the holdup is considered, then the models of calculating overall superficial velocity and phase superficial velocity are determined. Based on experiments, the parameters of the calculation model are determined respectively under different continuous phases. The experimental results show that the superficial flow velocities calculated by the model are in good agreement with the actual flow velocities. The relative error of the overall superficial velocity is less than 6.32%, and root mean square error of phase superficial velocity is within 5.64%.

Key words: capacitance and conductance, double modal, flow velocity measurement, oil-water two-phase flow, ultrasound Doppler

中图分类号:

TH815
TP216

史雪薇, 谭超, 董虓霄, 董峰. 超声多普勒谱修正的油水两相流流速测量[J]. 机械工程学报, 2017, 53(24): 77-84.

SHI Xuewei, TAN Chao, DONG Xiaoxiao, DONG Feng. Oil-water Two-phase Flow Velocity Measurement Based on Ultrasonic Doppler Spectrum Correction[J]. Journal of Mechanical Engineering, 2017, 53(24): 77-84.

参考文献

[1] HEWITT G F. Measurement of two phase flow parameters[M]. London:Academic Press, 1978.
[2] HUANG Zhiyao, LI Xia, LIU Yian, et al. Experimental study on performance of turbine flowmeter and venturi meter in oil-water two-phase flow measurement[C]//AIP Conference Proceedings, New York:American Institute of Physics, 2007:678-682.
[3] TAN Chao, WU Hao, DONG Feng. Mass flow rate measurement of oil-water two-phase flow by a long-waist cone meter[J]. IEEE Transactions on Instrumentation and Measurement, 2013, 62(10):2795-2804.
[4] 贺登辉, 张锋, 曹洪贵, 等. 基于单V锥节流装置的湿气气液流量在线测量[J]. 机械工程学报, 2016, 52(8):191-197. HE Denghui, ZHANG Feng, CAO Honggui, et al. Online measurement of gas and liquid flow rate in wet gas base on single V-cone throttle[J]. Journal of Mechanical Engineering, 2016, 52(8):191-197.
[5] WANG Chao, ZHANG Jingyu, GAO Wenbin, et al. Cross-correlation focus method with an electrostatic sensor array for local particle velocity measurement in dilute gas-solid two-phase flow[J]. Measurement Science & Technology, 2015, 26:115301-115310.
[6] LUCAS G P, JIN Ningde. Measurement of the homogeneous velocity of inclined oil-in-water flows using a resistance cross correlation flow meter[J]. Measurement Science & Technology, 2001, 12(9):1529-1537.
[7] 郑丹丹, 张朋勇, 徐天室. 超声流量计探头安装位置对测量影响数值仿真研究[J]. 机械工程学报, 2011, 47(12):13-18. ZHENG Dandan, ZHANG Pengyong, XU Tianshi. Effect of installation position of ultrasonic flowmeter probe on flow measurement[J]. Journal of Mechanical Engineering, 2011, 47(12):13-18.
[8] NGUYEN T T, KIKURA H, DUONG N H, et al. Measurements of single-phase and two-phase flows in a vertical pipe using ultrasonic pulse Doppler method and ultrasonic time-domain cross-correlation method[J]. Vietnam Journal of Mechanics, 2013, 35(3):239-256.
[9] LI Xia, HUANG Zhiyao, MENG Zhenzhen, et al. Oil-water two-phase flow measurement using a venturi meter and an oval gear flow meter[J]. Chemical Engineering Communications, 2009, 197(2):223-231.
[10] CHEN Jianjun, XU Lijun, CAO Zhang, et al. Water cut measurement of oil-water flow in vertical well by combining total flow rate and the response of a conductance probe[J]. Measurement Science and Technology, 2015, 26(9):112.
[11] OLIVEIRA J L G, PASSOS J C, VERSCHAEREN R, et al. Mass flow rate measurements in gas-liquid flows by means of a venturi or orifice plate coupled to a void fraction sensor[J]. Experimental Thermal and Fluid Science, 2009, 33(2):253-260.
[12] TAN Chao, DAI Wei, YEUNG Hoi, et al. A Kalman estimation based oil-water two-phase flow measurement with CRCC[J]. International Journal of Multiphase Flow, 2015, 72:306-317.
[13] BRODY W R, MEINDL J D. Theoretical analysis of the CW Doppler ultrasonic flowmeter[J]. IEEE Transactions on Biomedical Engineering, 1974, 21(3):183-192.
[14] TAKEDA Y. Development of an ultrasound velocity profile monitor[J]. Nuclear Engineering and Design, 1991, 126(2):277-284.
[15] MURAKAWA H, KIKURA H, ARITOMI M. Measurement of liquid turbulent structure in bubbly flow at low void fraction using ultrasonic Doppler method[J]. Journal of Nuclear Science and Technology, 2003, 40(9):644-654.
[16] IHARA T, KIKURA H, TAKEDA Y. Ultrasonic velocity profiler for very low velocity field[J]. Flow Measurement. and Instrumentation, 2013, 34:127-133.
[17] DONG Xiaoxiao, TAN Chao, YUAN Ye, et al. Oil-water two-phase flow velocity measurement with continuous wave ultrasound Doppler[J]. Chemical Engineering Science, 2015, 135:155-165.
[18] 董虓霄, 谭超, 董峰. 超声多普勒水连续油水分散流流速测量方法[J]. 工程热物理学报, 2016, 37(4):775-779. DONG Xiaoxiao, TAN Chao, DONG Feng. Water continuous dispersed oil-water two-phase flow velocity measurement based on ultrasonic Doppler[J]. Journal of Engineering Thermophysics, 2016, 37(4):775-779.
[19] VIKOMERSON D, RICCI S, TORTOLI P. Finding the peak velocity in a flow from its Doppler spectrum[J]. IEEE Transactions on Ultrasonics Ferroelectrics & Frequency Control, 2013, 60(10):2079-2088.
[20] RICCI S, MATERA R, TORTOLI P. An improved Doppler model for obtaining accurate maximum blood velocities[J]. Ultrasonics, 2014, 54(7):2006-2014.
[21] ELSETH G. An experimental study of oil/water flow in horizontal pipes[D]. Porsgrunn:The Norwegian University of Science and Technology (NTNU), 2001.
[22] FOSSA M. Design and performance of a conductance probe for measuring the liquid fraction in two-phase gas-liquid flows[J]. Flow Measurement and Instrumentation, 1998, 9(2):103-109.

超声多普勒谱修正的油水两相流流速测量

Oil-water Two-phase Flow Velocity Measurement Based on Ultrasonic Doppler Spectrum Correction

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

本文评价

[1]	李文广;薛敦松. 离心泵叶轮内部粘油流动激光测速计测量[J]. , 1998, 34(6): 97-101，.
[2]	张晓光;徐健键;林学栋. 润滑脂管道流动阻力的测试研究[J]. , 2005, 41(10): 185-192.
[3]	李扬;郑莹娜;汪仁煌. 光电式固体微粒流量计的理论模型与试验研究[J]. , 2004, 40(8): 160-165.