高速列车齿轮箱载荷特性分析

doi:10.3901/JME.2018.04.270

摘要/Abstract

摘要： 以某型动车组齿轮箱为研究对象，建立齿轮箱隔振橡胶的有限元模型，分析载荷频率、振幅及预载荷对橡胶非线性刚度的影响规律。通过吊杆力传感器获得齿轮箱载荷时间历程，分析列车在启动牵引、制动停车、高低速直线运行及坡道运行等典型工况下齿轮箱载荷的时程曲线及载荷变化规律。在数据统计基础上得到齿轮箱趋势载荷对动态载荷及动态载荷谱的影响规律，同时定义疲劳损伤影响参数来分析不同载荷对结构整体损伤的影响程度。研究结果表明，在一定作用频率范围内，橡胶非线性刚度受频率影响较小，随着预载荷的增大而增大；趋势载荷的增大使齿轮箱动载荷幅值呈现出明显的增大趋势；趋势载荷和动态载荷单独作用下的疲劳损伤影响参数值分别为0.04、0.69，载荷谱中舍弃趋势载荷会导致结构疲劳损伤值降低31%。该研究结果在高速列车齿轮箱的仿真分析及国产化研究等方面具有一定参考价值。

关键词: 齿轮箱, 隔振橡胶, 疲劳损伤, 趋势载荷, 载荷特性

Abstract: Taking the gearbox of a certain model as the research object, the finite element model of vibration isolation rubber is established to analyze the effect of load frequency, amplitude and pre-load on the nonlinear stiffness of the rubber. The gearbox load is obtained by the suspension bar force sensor. The load time history and distribution characteristics are provided under typical service cases such as starting, braking, straight line running, slope passing, and so on. On the basis of statistics, the influence of trend load on dynamic load and load spectrum are studied. The fatigue damage influence parameter is defined to analyze the influence of different loads on the structural damage. It is shown that in a certain load frequency range, the nonlinear stiffness of the rubber is less affected by the frequency and it increases with the increase of pre-load. The increase of trend load makes the amplitude of dynamic load increase obviously. The influence parameter values of fatigue damage caused by trend load and dynamic load are 0.04 and 0.69. It would decrease 31% if the trend load is not considered in the load spectrum compilation. The research result provides a certain degree of reference for simulation and domestic design of the gearbox.

Key words: fatigue damage, gearbox, load characteristics, trend load, vibration isolating rubber

中图分类号:

U260

李广全, 王文静, 杨广雪. 高速列车齿轮箱载荷特性分析[J]. 机械工程学报, 2018, 54(4): 270-277.

LI Guangquan, WANG Wenjing, YANG Guangxue. Analysis on Load Characteristics of High-speed Train Gearbox[J]. Journal of Mechanical Engineering, 2018, 54(4): 270-277.

参考文献

[1] 王文静,惠晓龙,马纪军. 高速列车设备舱支架疲劳裂纹机理研究[J]. 机械工程学报,2015,51(6):142-147. WANG Wenjing,HUI Xiaolong,MA Jijun. Fatigue crack mechanism research on high speed train equipment cabin frame[J]. Journal of Mechanical Engineering,2015,51(6):142-147.
[2] 任尊松,孙守光,李强. 高速动车组轴箱弹簧载荷动态特性[J]. 机械工程学报,2010,46(10):109-114. REN Zunsong,SUN Shouguang,LI Qiang. Axle spring load test and dynamic characteristics analysis of high speed EMU[J]. Journal of Mechanical Engineering,2010,46(10):109-114.
[3] 李广全,刘志明,王文静,等. 高速动车组齿轮箱疲劳裂纹机理分析研究[J]. 机械工程学报,2017,53(2):99-105. LI Guangquan,LIU Zhiming,WANG Wenjing,et al. Fatigue crack mechanism study on high-speed EMU gearbox[J]. Journal of Mechanical Engineering,2017,53(2):99-105.
[4] RAGHOTHAMA A,NARAYANAN S. Bifurcation and chaos in geared rotor bearing system by incremental harmonic balance method[J]. Journal of Sound and Vibration,1999,226(3):469-492.
[5] 朱才朝,陆波,宋朝省,等. 大功率船用齿轮箱系统耦合非线性动态特性的研究[J]. 机械工程学报,2009,45(9):31-35. ZHU Caichao,LU Bo,SONG Chaosheng,et al. Research on nonlinear coupling dynamitic characteristics of large burden marine gearbox[J]. Journal of Mechanical Engineering,2009,45(9):31-35.
[6] SEYRANIAN A P,SOLEM F,PEDEREEN P. Multi-parameter linear periodic systems:Sensitivity analysis and applications[J]. Journal of Sound and Vibration,2000,229(1):89-111.
[7] 魏静,孙清超,孙伟,等. 大型风电齿轮箱系统耦合动态特性研究[J]. 振动与冲击,2012,31(8):16-23. WEI Jing,SUN Qingchao,SUN Wei,et al. Dynamical coupling characteristics of a large wind turbine gearbox transmission system[J]. Journal of Vibration and Shock,2012,31(8):16-23.
[8] 黄冠华,王兴宇,梅桂明,等. 内外激励下高速列车齿轮箱箱体动态响应分析[J]. 机械工程学报,2015,51(12):95-100. HUANG Guanhua,WANG Xingyu,MEI Guiming,et al. Dynamic response analysis of gearbox housing system subjected to internal and external excitation in high-speed train[J]. Journal of Mechanical Engineering,2015,51(12):95-100.
[9] 常程城. 高速列车齿轮箱线路试验及振动传递关系研究[D]. 北京:北京交通大学,2015. CHANG Chengcheng. Transmission relationship between high-speed train gearbox line test and vibration[D]. Beijing:Beijing Jiaotong University,2015.
[10] 袁雨青,李强,杨光,等. 高速列车齿轮箱线路测试与异常振动分析[J]. 铁道机车车辆,2016,36(1):24-29. YUAN Yuqing,LI Qiang,YANG Guang,et al. Line test and abnormal vibration analysis of high-speed train gearbox[J]. Railway Locomotive & Car,2016,36(1):24-29.
[11] 周易文,栗付平,张国杰,等. 一种CRH3型动车组用V型橡胶减振器额定承载条件下动态特性有限元分析[J]. 特种橡胶制品,2015,36(6):61-65. ZHOU Yiwen,LI Fuping,ZHANG Guojie,et al. Finite element analysis on the dynamic characteristic of working-loaded V rubber mount used in CRH3 EMU[J]. Special Purpose Rubber Products,2015,36(6):61-65.
[12] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会. GB/T15168-94振动与冲击隔振器性能测试方法[S]. 北京:中国标准出版社,1998. General Administration of Quality Supervision, Inspection and Quarantine of the People's Republic of China, Standardization Administration of the People's Republic of China. GB/T15168-94 Vibration and shock isolators measuring method for its characteristics[S]. Beijing:Standards Press of China,1998.
[13] 和法家,卢曦. 某直升机橡胶减震器非线性刚度特性试验[J]. 实验室研究与探索,2014,33(3):41-44. HE Fajia,LU Xi. Experimental research on dynamic stiffness characteristics of a rubber-shock-absorber[J]. Research and Exploration in Laboratory,2014,33(3):41-44.
[14] 任尊松,刘志明. 高速动车组振动传递及频率分布规律[J]. 机械工程学报,2013,49(16):1-7. REN Zunsong,LIU Zhiming. Vibration and frequency domain characteristics of high speed EMU[J]. Journal of Mechanical Engineering,2013,49(16):1-7.
[15] CHENG Junsheng,YU Dejie,YANG Yu. Research on the intrinsic mode function (IMF) criterion in EMD method[J]. Multichannel Systems and Signal Processing,2006,20(4):817-824.
[16] 姜涛,付志翼,王安麟. 一种非平稳随机循环工况下的参数化载荷模型[J]. 东北大学学报,2016,37(6):845-850. JIANG Tao,FU Zhiyi,WANG Anlin. Parameterized load model under non-stationary random cyclic conditions[J]. Journal of Northeastern University,2016,37(6):845-850.
[17] SWAMI A,MENDE J M. ARMA parameter estimation using only output cumulants[J]. IEEE Translation on Acoustics Speech & Signal Processing,1990,38(7):1257-1265.
[18] 高镇同. 载荷谱的编制[J]. 航空学报,1980,2(2):36-37. GAO Zhentong. Load spectrum establishment[J]. Journal of Aviation,1980,2(2):36-37.
[19] 薛海,李强. 1万t重载组合列车的车钩力特性分析[J]. 中国铁道科学,2016,37(3):88-94. XUE Hai,LI Qiang. Characteristics analysis of coupler force for 10000 t heavy haul combined train[J]. China Railway Science,2016,37(3):88-94.
[20] 赵方伟,谢基龙. 小应力循环对C70E型车体疲劳损伤的影响研究[J]. 机械工程学报,2015,50(10):121-126. ZHAO Fangwei,XIE Jilong. Influence of small stress cycles on the fatigue damage of C70E car body[J]. Journal of Mechanical Engineering,2015,50(10):121-126.