• CN:11-2187/TH
  • ISSN:0577-6686

机械工程学报 ›› 2016, Vol. 52 ›› Issue (20): 151-158.doi: 10.3901/JME.2016.20.151

• 可再生能源与工程热物理 • 上一篇    下一篇

高原环境增压器离心压气机特性试验研究

李书奇, 刘畅, 胡力峰, 邢卫东, 杨震寰   

  1. 中国北方发动机研究所柴油机增压技术重点实验室 天津 300400
  • 出版日期:2016-10-20 发布日期:2016-10-20
  • 作者简介:

    李书奇,男,1981年出生,副研究员。主要研究方向为涡轮增压器设计与应用。

    E-mail:lishuqi_0202101@163.com

Experimental Investigation on Centrifugal Compressor Performance Characteristics of Plateau Environment for Vehicle Turbocharger

LI Shuqi, LIU Chang, HU Lifeng, XING Weidong, YANG Zhenhuan   

  1. Science and Technology on Diesel Engine Turbocharging Laboratory,China North Engine Research Institute, Tianjin 300400
  • Online:2016-10-20 Published:2016-10-20

摘要:

针对所研制的高压比涡轮增压器压气机,基于构建的进气高原模拟试验台架,开展高原环境下车用增压器压气机特性试验分析与研究,以探讨高压比压气机高原特性的变化规律,并获得相应的验模试验数据。结果表明:在高原环境下,随着海拔的升高,压气机质量流量减小,同转速下最高压比基本保持不变,效率、雷诺数有所降低。海拔自1 000 m升高至4 500 m,质量流量减小26%~44%,效率降低1%~3.5%,压气机进口气体雷诺数降低约30%,近50%以上工况不满足雷诺数处于自模区假设。同时,压气机稳定工作流量范围拓宽,最高可拓宽11%,发生在高压比高转速工况。随海拔的升高,压气机体积流量减小,体积流量特性变化幅度较小,约3%(小于折合质量流量变化特性);因此,忽略系统效应的喘振线差异,可以采用体积流量特性进行变海拔高原环境离心压气机特性及内部流动对比研究。在高原环境下,以折合参数绘制的通用特性与零海拔特性差别较大,尤其是4 500 m海拔,不具备较好的可比性和参照性;而以相似参数绘制的通用特性同时也存在差异,但与折合流量特性、实际流量特性相比,随海拔变化最小,可用于不同海拔特性对比研究。由于雷诺数变化的影响,离心压气机特性随海拔高度存在差异,以马赫数相似为基础的特性曲线绘制方法存在偏差,不再有效;此时,对压气机在高原特性的研究,需要采用实际流量和实际转速;但在不同海拔特性曲线对比研究方面,采用相似参数为基础绘制的特性曲线具有较好的直观可比性。

关键词: 高原环境, 雷诺数, 特性, 增压器, 离心压气机

Abstract:

For the high pressure ratio centrifugal compressor of turbocharger, based on plateau environment simulation test rig for inlet environment system, do study on experimental investigation for impact on compressor performance at high altitude in order to deal with the problem of compressor characteristic estimation with diesel engine at plateau regions. The research data analysis show the following conclusions: At the high altitude, the mass flow rate of compressor decrease, the maximum pressure ratio at the same speed hold approximately invariability, but the efficiency and Reynolds number reduce too. From 1 000 m altitude to 4 500 m altitude, the mass flow rate decrease by 26%-44%, and the efficiency have 1-3.5 percentage fall. The inlet Reynolds number decrease by 30% , cause to more than 50% operation out of the self-mode critical region. The stable flow range is going to broad, and the maximum increase is 11%. The volume flow rate of compressor decrease at high altitude from 1 000 m altitude to 4 500 m, the maximum flow rate decrease is 3%, smaller than the referred parameter difference. The general characteristics with referred parameter have the big difference at high altitude, especially for 4 500 m altitude, don’t have comparative and reference function. The general characteristics with similitude parameter have small change, can be used to research on different altitude contrast. At high altitude, due to the effect of Reynolds number, the general performance characteristics based on Mach number similitude theory don’t have good and exact results, and we have to use the actual flow rate and speed performance characteristics in study on high altitude, but the method with similitude parameter can clearly and directly compare on different altitude performance.

Key words: performance, plateau environment, Reynolds number, turbocharger, centrifugal compressor