四轮独立驱动汽车多工况路面附着系数识别研究

doi:10.3901/JME.2019.22.080

机械工程学报 ›› 2019, Vol. 55 ›› Issue (22): 80-92.doi: 10.3901/JME.2019.22.080

扫码分享

四轮独立驱动汽车多工况路面附着系数识别研究

平先尧¹, 李亮¹, 程硕¹, 王恒阳²

1. 清华大学汽车安全与节能国家重点实验室北京 100084;
2. 北京交通大学电气工程学院北京 100044

收稿日期:2019-08-31 修回日期:2019-11-07 出版日期:2019-11-20 发布日期:2020-02-29
通讯作者: 李亮(通信作者),男,1976年出生,博士,教授,博士研究生导师。主要研究方向为车辆动力学与控制和混合动力系统控制。E-mail:liangl@tsinghua.edu.cn
作者简介:平先尧,男,1997年出生。主要研究方向为车辆动力学与控制。E-mail:pingxy18@mails.tsinghua.edu.cn
基金资助:
国家重点研发计划（2017YFB0103902）和国家自然科学基金（51675293）资助项目。

Tire-Road Friction Coefficient Estimators for 4WID Electric Vehicles on Diverse Road Conditions

PING Xianyao¹, LI Liang¹, CHENG Shuo¹, WANG Hengyang²

1. State Key Laboratory of Automotive Safety and Energy, Tsinghua University, Beijing 100084;
2. School of Electrical Engineering, Beijing Jiaotong University, Beijing 100044

Received:2019-08-31 Revised:2019-11-07 Online:2019-11-20 Published:2020-02-29

摘要/Abstract

摘要： 四轮独立驱动（Four-wheel independent drive， 4WID）电动汽车具有较好的动力学稳定性协调控制潜力，轮胎-路面附着系数的识别是汽车操纵性能控制的基础。基于视觉传感器的路面识别方案成本高，传统卡尔曼滤波算法观测精度低且难以适应含有时变结构的非线性系统。众多研究已详细介绍均一路面附着系数的估计方法，尚未充分考虑对接和对开路面的观测方案。本研究将强跟踪理论（Strong tracking theory， STT）引入无迹卡尔曼滤波（Unscented Kalman filter， UKF）算法，构造强跟踪无迹卡尔曼滤波（Strong tracking unscented Kalman filter， STUKF）观测器，提高识别算法的识别精度，以及对时变附着系数的适应能力。考虑多重渐消因子计算过程的复杂性，本研究降低四轮路面识别模型的维数，构造两个含单重渐消因子矩阵的二维观测器，实时观测四个轮胎-路面附着系数。仿真和试验结果表明，与传统四维UKF算法相比，改进的并联STUKF算法能够更加有效地追踪转向或直行工况下均一路面、对接路面和对开路面的四轮附着系数。

关键词: 四轮独立驱动, 路面附着系数, 强跟踪理论, 无迹卡尔曼滤波, 渐消因子矩阵

Abstract: Four-wheel independent drive (4WID) electric vehicle has large potential in dynamics stability coordination control, and the estimation of each tire-road friction coefficient is the foundation of its maneuverability control. The cost of visual sensors-based observation scheme can be high, and traditional Kalman filter has limited estimation accuracy and is not adapt well to nonlinear system with time-varying structures. Most model-based researches have studied the estimation methods for uniform road surfaces in depth, and not fully considered the observation schemes for joint and μ-split road surfaces. Strong tracking theory (STT) is introduced to unscented Kalman filter (UKF) for the construction of Strong Tracking Unscented Kalman Filter (STUKF) with higher filter accuracy and good adaptability to time-varying friction coefficient. After complex computation procedure of multiple fading factors has been considered, the dimension-reduction method of four dimensional observation model is discussed. Two lower dimension estimators with single fading factor matrix are built as so to observe four tire-road friction coefficients in real time. Compared with traditional four dimensional UKF-based estimator, improved parallel estimators based on STUKF algorithm could track true values of these coefficients more effectively on the cornering and straight driving conditions of the joint and μ-split roads.

Key words: four-wheel independent drive, tire-road friction coefficient, strong tracking theory, unscented Kalman filter, fading factor matrix

中图分类号:

U469

平先尧, 李亮, 程硕, 王恒阳. 四轮独立驱动汽车多工况路面附着系数识别研究[J]. 机械工程学报, 2019, 55(22): 80-92.

PING Xianyao, LI Liang, CHENG Shuo, WANG Hengyang. Tire-Road Friction Coefficient Estimators for 4WID Electric Vehicles on Diverse Road Conditions[J]. Journal of Mechanical Engineering, 2019, 55(22): 80-92.

参考文献

[1] CHEN Y,WANG J. Adaptive vehicle speed control with input injections for longitudinal motion independent road frictional condition estimation[J]. IEEE Transactions on Vehicular Technology,2011,60(3):839-848.
[2] CHEN J,SONG J,LI L,et al. UKF-based adaptive variable structure observer for vehicle sideslip with dynamic correction[J]. IET Control Theory&Applications,2016,10(14):1641-1652.
[3] 陈杰.电子稳定控制系统控制策略及关键问题研究[D].北京:清华大学,2017. CHEN Jie. Research on control strategy and key problems of electronic stability control system[D]. Beijing:Tsinghua University,2017.
[4] 李亮,朱宏军,陈杰,等.用于汽车稳定性控制的路面附着识别算法[J].机械工程学报,2014,50(2):132-138. LI Liang,ZHU Hongjun,CHEN Jie,et al. Road friction identification algorithm for the vehicle stability control[J]. Journal of Mechanical Engineering,2014,50(2):132-138.
[5] 王震坡,丁晓林,张雷.四轮轮毂电机驱动电动汽车驱动防滑控制关键技术综述[J].机械工程学报,2019,55(12):99-120. WANG Zhenpo,DING Xiaolin,ZHANG Lei. Overview on key technologies of acceleration slip regulation for four-wheel-independently-actuated electric vehicles[J]. Journal of Mechanical Engineering,2019,55(12):99-120.
[6] KHALEGHIAN S,EMAMI A,TAHERI S. A technical survey on tire-road friction estimation[J]. Friction,2017,5(2):123-146.
[7] 余卓平,曾德全,熊璐,等.基于激光雷达的无人车路面附着系数估计[J].华中科技大学学报,2019,47(7):124-127. YU Zhuoping,ZENG Dequan,XIONG Lu,et al. Road adhesion coefficient estimation for unmanned vehicle based on lidar[J]. Journal of Huazhong University of Science and Technology,2019,47(7):124-127.
[8] WANG Y,ZHOU Z,WEI C,et al. Host-target vehicle model-based lateral state estimation for preceding target vehicles considering measurement delay[J]. IEEE Transactions on Industrial Informatics,2018,9(14):4190-4199.
[9] HAHN J,RAJAMANI R,ALEXANDER L. GPS-based real-time identification of tire-road friction coefficient[J]. IEEE Transactions on Control Systems Technology,2002,10(3):331-343.
[10] ANDERSON R,BEVLY D. Using GPS with a model-based estimator to estimate critical vehicle states[J]. Vehicle System Dynamics,2010,48(12):1413-1438.
[11] SINGH K B,ARAT M A,TAHERI S. Literature review and fundamental approaches for vehicle and tire state estimation[J]. Vehicle System Dynamics,2018,57(11):1-23.
[12] SHAO L,JIN C,LEX C,et al. Robust road friction estimation during vehicle steering[J]. Vehicle System Dynamics,2018,57(4):1-27.
[13] 刘力,罗禹贡,李克强.基于归一化轮胎模型的路面附着系数观测[J].清华大学学报,2009,49(5):116-120. LIU Li,LUO Yugong,LI Keqiang. Tire-road friction coefficient estimation based on normalized tire model[J]. Journal of Tsinghua University,2009,49(5):116-120.
[14] 武钟财.基于扩展卡尔曼滤波的路面附着系数估计算法研究[D].长春:吉林大学,2008. WU Zhongcai. Research on the algorithm of the road friction coefficient estimation based on the extended Kalman filter[D]. Changchun:Jilin University,2008.
[15] 赵万忠,张寒,王春燕.基于无迹卡尔曼滤波的汽车状态参数估计[J].华南理工大学学报,2016,44(3):76-80. ZHAO Wanzhong,ZHANG Han,WANG Chunyan. UKF-based estimator for the vechiles'state parameters[J]. Journal of South China University of Technology,2016,44(3):76-80.
[16] CHENG Q,CORREA-VICTORINO A,CHARARA A. A new nonlinear observer using unscented Kalman filter to estimate sideslip angle,lateral tire road forces and tire road friction coefficient[C]//2011 IEEE Intelligent Vehicles Symposium (IV),2011:709-714.
[17] ANTONOV S,FEHN A,KUGI A. Unscented Kalman filter for vehicle state estimation[J]. Vehicle System Dynamics,2011,49(9):1497-1520.
[18] CHENG S,LI L,CHEN J. Fusion algorithm design based on adaptive SCKF and integral correction for side-slip angle observation[J]. IEEE Transactions on Industrial Electronics,2018,65(7):5754-5763.
[19] HAN B,HUANG H,LEI L,et al. An improved IMM algorithm based on STSRCKF for maneuvering target tracking[J]. IEEE Access,2019,20(7):57795-57804.
[20] GAO X,YU Z,NEUBECK J,et al. Sideslip angle estimation based on input-output linearization with tire-road friction adaptation[J]. Vehicle System Dynamics,2010,48(2):217-234.
[21] 薛海建,郭晓松,周召发.基于自适应多重渐消因子卡尔曼滤波的SINS初始对准方法[J].系统工程与电子技术,2017,39(3):620-626. XUE Haijian,GUO Xiaosong,ZHOU Zhaofa. SINS initial alignment method based on adaptive multiple fading factors Kalman filter[J]. System Engineering and Electronics,2017,39(3):620-626.
[22] 张浩.基于强跟踪无迹卡尔曼滤波的结构时变参数识别[D].兰州:兰州理工大学,2016. ZHANG Hao. Structural time-varying parameter identification based on strong tracking unscented Kalman filter[D]. Lanzhou:Lanzhou University of Technology,2016.
[23] SONG Y,SHU H,CHEN X,et al. Direct-yaw-moment control of four-wheel-drive electrical vehicle based on lateral tyre-road forces and sideslip angle observer[J]. IET Intelligent Transport Systems,2019,13(2):303-312.
[24] 黄小平,王岩.卡尔曼滤波原理及应用[M].北京:电子工业出版社,2015. HUANG Xiaoping,WANG Yan. Principle and application of Kalman filter[M]. Beijing:Publishing House of Electronics Industry,2015.

四轮独立驱动汽车多工况路面附着系数识别研究

Tire-Road Friction Coefficient Estimators for 4WID Electric Vehicles on Diverse Road Conditions

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 9

编辑推荐

Metrics

本文评价

[1]	赵明慧, 郭浩然, 张利鹏, 刘欣. 四轮独立转向分布式驱动电动汽车单轮转向失效行驶稳定性控制[J]. 机械工程学报, 2024, 60(10): 507-522.
[2]	徐向阳, 李光远, 陶斯友, 张辉. 四轮独立驱动电动汽车轮胎纵横向滑移能耗仿真分析[J]. 机械工程学报, 2021, 57(4): 92-102.
[3]	林棻, 王少博, 赵又群, 蔡亦璋. 基于改进Keras模型的路面附着系数估计[J]. 机械工程学报, 2021, 57(12): 74-86.
[4]	宋义彤, 舒红宇, 陈仙宝, 靖长青, 郭成. 分布式电动汽车状态与参数无迹卡尔曼滤波估计[J]. 机械工程学报, 2020, 56(16): 204-213.
[5]	周洪亮, 贾凤娇, 刘志远, 刘海峰. 四轮独立驱动汽车驱动系统故障诊断与容错控制[J]. 机械工程学报, 2019, 55(22): 174-182.
[6]	金贤建, 杨俊朋, 殷国栋, 王金湘, 陈南, 卢彦博. 分布式驱动电动汽车双无迹卡尔曼滤波状态参数联合观测[J]. 机械工程学报, 2019, 55(22): 93-102.
[7]	谢有浩, 赵林峰, 陈无畏, 刘彦琳. 低附着路面条件的线控转向系统路感模拟与回正控制研究[J]. 机械工程学报, 2019, 55(16): 148-158.
[8]	赵治国, 杨杰, 陈海军, 吴枭威. 四驱混合动力轿车驱动工况无迹卡尔曼车速估计[J]. 机械工程学报, 2015, 51(4): 96-107.
[9]	李亮;朱宏军;陈杰;宋健;冉旭. 用于汽车稳定性控制的路面附着识别算法[J]. , 2014, 50(2): 132-138.