过滤-旋流耦合技术在非均相分离中的研究及应用

doi:10.3901/JME.2022.04.120

机械工程学报 ›› 2022, Vol. 58 ›› Issue (4): 120-154.doi: 10.3901/JME.2022.04.120

• 可再生能源与工程热物理 • 上一篇下一篇

扫码分享

过滤-旋流耦合技术在非均相分离中的研究及应用

刘洋^1,2, 赵立新^1,2, 张爽^1,2, 刘琳^1,2, 徐保蕊^1,2

1. 东北石油大学机械科学与工程学院大庆 163318;
2. 黑龙江省石油石化多相介质处理及污染防治重点实验室大庆 163318

收稿日期:2021-03-05 修回日期:2021-09-09 出版日期:2022-02-20 发布日期:2022-04-30
通讯作者: 赵立新(通信作者),男,1972年出生,博士,教授,博士研究生导师。主要研究方向为以旋流分离和离心分离为特色的多相介质分离技术、流体机械及工程技术。
作者简介:刘洋,男,1983年出生,博士研究生。主要研究方向为过滤及旋流分离技术。E-mail:nepuliuyang@hotmail.com;张爽,女,1997年出生,博士研究生。主要研究方向为流体机械及工程技术。E-mail:793879419@qq.com;刘琳,男,1992年出生,博士研究生。主要研究方向为旋流分离技术及油田水处理。E-mail:liulin@stu.nepu.edu.cn;徐保蕊,男,1985年出生,博士,讲师。主要研究方向为油田采出液水处理技术、旋流分离等流体机械工程技术。E-mail:xubaorui2009@126.com
基金资助:
国家重点研发计划"政府间国际科技创新合作"重点专项(2018YFE 0196000)、黑龙江省自然科学基金(重点项目)(ZD2020E001)和东北石油大学"龙江学者"配套支持计划(lj201803)资助项目。

Research and Application of Filtering-swirl Coupling Technology in Heterogeneous Separation

LIU Yang^1,2, ZHAO Lixin^1,2, ZHANG Shuang^1,2, LIU Lin^1,2, XU Baorui^1,2

1. School of Mechanical Science and Engineering, Northeast Petroleum University, Daqing 163318;
2. Heilongjiang Key Laboratory of Petroleum and Petrochemical Multiphase Treatment and Pollution Prevention, Daqing 163318

Received:2021-03-05 Revised:2021-09-09 Online:2022-02-20 Published:2022-04-30

摘要/Abstract

摘要： 过滤-旋流耦合分离装置作为一种新型分离设备，将旋流分离与过滤相结合，既充分地发挥传统水力旋流器的快速、高效、旋转涡流运动等优点，又通过深度过滤而提高传统水力旋流器的分离精度。从其各种形式的结构特点和工作原理的不同出发，阐述一些具有代表性和实用性的内置式、外置式、壁面过滤式分离器的研究成果。分别针对入口、旋流腔、溢流管、锥段、底流管、过滤材料等部分的结构参数，以及从针对入口流量、压力降和压降比、固体颗粒特性、流体特性、分流比/底流率、增压方式等操作工况和介质条件的研究现状出发，重点讨论分析过滤-旋流耦合分离装置的结构参数和操作工况在非均相介质分离中的影响情况，并展望将过滤-旋流耦合分离与其他分离工艺相结合，研发新型分离技术与设备将成为过滤-旋流耦合分离技术的潜在研究方向。

关键词: 水力旋流器, 过滤, 耦合, 固-液分离, 气-液分离

Abstract: As a new emerging separation equipment, the filter-cyclone coupling separation device combines cyclone separation with filtration, which not only sufficiently exerted play to the advantages of the traditional hydrocyclone such as rapid, high-efficiency, and swirling vortex motion, but also enhances the separation accuracy of the traditional hydrocyclone with the deep filtering separation. The research results of some representative and practical built-in, external and wall-filtered separators are described from the differences of their various forms of structural characteristics and operating principles. Respectively Starting from the current research status on the structural parameters of the inlet, cyclone cavity, overflow pipe, cone section, underflow pipe, and filter material, etc., as well as on the operating conditions and media conditions such as inlet flow rate, pressure drop and pressure drop ratio, solid particle characteristics, fluid characteristics, split ratio/underflow rate, and booster mode, etc., are discussed and analyzed, focusing on the structural parameters and operating conditions of the filter-cyclone coupling separation device in the non-homogeneous media. Combining filtration-cyclone coupling separation with other separation processes, the development of new separation technologies and equipment will become the potential research direction of filtration-cyclone coupling separation technology.

Key words: hydrocyclone, filtration, coupling, solid-liquid separation, gas-liquid separation

中图分类号:

TG231

刘洋, 赵立新, 张爽, 刘琳, 徐保蕊. 过滤-旋流耦合技术在非均相分离中的研究及应用[J]. 机械工程学报, 2022, 58(4): 120-154.

LIU Yang, ZHAO Lixin, ZHANG Shuang, LIU Lin, XU Baorui. Research and Application of Filtering-swirl Coupling Technology in Heterogeneous Separation[J]. Journal of Mechanical Engineering, 2022, 58(4): 120-154.

参考文献

[1] KELSALL D F. A study of the motion of solid particles in a hydraulic cyclone[R]. Harwell:Atomic Energy Research Establishment,1952.
[2] 蒋明虎,赵立新,李枫,等.旋流分离技术[M].哈尔滨:哈尔滨工业大学出版社,2000.JIANG Minghu,ZHAO Lixin,LI Feng,et al. Cyclone separation technology[M]. Harbin:Harbin Institute of Technology Press,2000.
[3] 贺杰,蒋明虎,宋华.新型油水分离装置——水力旋流器试验[J].石油机械,1993,(12):26-29,27.HE Jie,JIANG Minghu,SONG Hua. Experimental study on a new type of oil-water separation device:Hydrocyclone[J]. China Petroleum Machinery,1993(12):26-29,27.
[4] 徐保蕊,蒋明虎,赵立新.采出液黏度对三相分离旋流器性能的影响[J].机械工程学报,2017,53(8):175-182.XU Baorui,JIANG Minghu,ZHAO Lixin. Effect of production fluid viscosity on the performance of three phase separation hydrocyclone[J]. Journal of Mechanical Engineering,2017,53(8):175-182.
[5] 蒋明虎,谭放,金淑芹,等.基于Fluent网格变形的旋流器的形状优化[J].化工进展,2016,35(8):2355-2361.JIANG Minghu,TAN Fang,JIN Guiqin,et al. Sharp optimization of hydrocyclone based on Fluent mesh morphing[J]. Chemical Industry and Engineering Progress,2016,35(8):2355-2361.
[6] 赵立新,蒋明虎,孙德智.旋流分离技术研究进展[J].化工进展,2005(10):1118-1123.ZHAO Lixin,JIANG Minghu,SUN Dezhi. Research progress in cyclone separation technology[J]. Chemical Industry and Engineering Progress,2005(10):1118-1123.
[7] MENÉNDEZ-AGUADO L D,MARINA SÁNCHE Z M,RODRÍGUEZ M A,et al. Recycled mineral raw materials from quarry waste using hydrocyclones[J]. Materials,2019,12(13):2047.
[8] ZHANG Ting,WANG Xuesheng,CHEN,Qinzhu. Separation performance of hydrocyclone on emulsified oil wastewater floc[J]. IOP Conference Series:Earth and Environmental Science,2019,358(5):052016.
[9] 白春禄,王春升,陈家庆,等.油井采出液预分水用轴向水力旋流器的试验研究[J].化工进展,2020,39(5):1649-1656.BAI Chunlu,WANG Chunsheng,CHEN Jiaqing,et al. Experimental research on axial hydrocyclones for pre-separation of produced fluids in oil wells[J]. Chemical Industry and Engineering Progress,2020,39(5):1649-1656.
[10] NI Long,TIAN Jinyi,SHEN Chao,et al. Experimental study of the separation performance of a novel sewage hydrocyclone used in sewage source heat pump[J]. Applied Thermal Engineering,2016,106:1300-1310.
[11] PATRA G,BARNWAL R,BEHERA S K,et al. Removal of dyes from aqueous solution by sorption with fly ash using a hydrocyclone[J]. Journal of Environmental Chemical Engineering,2018,6(4):5204-5211.
[12] PIETRZYK S,PALIMAKA P,STEPIEŃ M,et al. Silver recovery from zinc metallurgical sludge-analysis of solutions[C]//Mineral Engineering Conforence. Wisla:EDP Sciences,2017,18(4):01027.
[13] ZHAO Lixin,JIANG Minghu,XU Baorui,et al. Development of a new type high-efficient inner-cone hydrocyclone[J]. Chemical Engineering Research and Design,2012,90(12):2129-2134.
[14] SHAH H,MAJUMDER A K,BARNWAL J P. Development of water split model for a 76 mm hydrocyclone[J]. Minerals Engineering,2006,19(1):102-104.
[15] HWANG K J,CHOU S P. Designing vortex finder structure for improving the particle separation efficiency of a hydrocyclone[J]. Separation and Purification Technology,2017,172:76-84.
[16] CHU Liangyin,LUO Qian. Hydrocyclone with high sharpness of separation[J]. Filtration and Separation,1994,31(7):733-720.
[17] WANG Lianze,YE Long. Reducing pressure drop in cyclones by a stick[J]. Aerosol Science and Technology,1999,31(2-3):187-193.
[18] WANG Lianze,YAN Qishen,LIU Linlan. Effect of a stick on the flow field in a cyclone and the pressure drop reduction mechanism[J]. Aerosol Science and Technology,2001,35(5):909-913.
[19] LIU Chengwen,WANG Lianze,LIU Qiusheng. Experimental study and analysis on drag reduction mechanisms of reducing pressure drop stick in a cyclone separator[J]. Chemical Engineering and Technology:Industrial Chemistry-Plant Equipment-Process Engineering-Biotechnology,2006,29(4):495-503.
[20] LIU Chengwen,WANG Lianze,LIU Qiusheng. A universal approach for mean mechanical energy losses analysis[J]. Chemical Engineering Science,2006,61(6):2085-2088.
[21] WANG Lianze,WANG Jiming. Experimental study of the drag reduction and separation efficiency for a new hydrocyclone with a reducing pressure drop stick[J]. Separation and Purification Technology,2012,98:7-15.
[22] CHU Liangyin,CHEN Wenmei,LEE Xiaozhong. Effect of structural modification on hydrocyclone performance[J]. Separation and Purification Technology,2000,21(1-2):71-86.
[23] SRIPRIYA R,KAULASKAR M D,CHAKRABORTY S,et al. Studies on the performance of a hydrocyclone and modeling for flow characterization in presence and absence of air core[J]. Chemical Engineering Science,2007,62(22):6391-6402.
[24] EVANS W K,SUKSANGPANOMRUNG A,NOWAKOWSKI A F. The simulation of the flow within a hydrocyclone operating with an air core and with an inserted metal rod[J]. Chemical Engineering Journal,2008,143(1-3):51-61.
[25] HUANG Long,DENG Songsheng,CHEN Zhi,et al. Numerical analysis of a novel gas-liquid pre-separation cyclone[J]. Separation and Purification Technology,2018,194:470-479.
[26] 周嘉钰,鄢曙光,熊攀,等.中心锥结构对水力旋流器内流场及分离效率影响的研究[J].矿产保护与利用,2018,4(6):65-69.ZHOU Jiayu,YAN Shuguang,XIONG Pan,et al. Research on the influence of central cone structure on the flow field and separation efficiency of hydrocyclones[J]. Conservation and Utilization of Mineral Resources,2018,4(6):65-69.
[27] 刘培坤,李子硕,杨兴华,等.中心曲面锥型旋流器分离性能的数值模拟[J].金属矿山,2020,4(12):184-189.LIU Peikun,LI Zishuo,YANG Xinghua,et al. Numerical simulation of separation performance of the hydrohydrocyclone with imbeded curve surface cone at the centre[J]. Metal Mine,2020,4(12):184-189.
[28] 赵立新,李宜强,徐保蕊,等.内锥直径对脱气除砂一体化旋流器影响研究[J].石油矿场机械,2014,43(10):31-34.ZHAO Lixin,LI Yiqiang,XU Baorui,et al. Study on the influence of inner cone diameter on integrated degassing and sand removal cyclone[J]. Oil Field Equipment,2014,43(10):31-34.
[29] 赵立新,王羕,罗雅君,等.溢流管结构对三相分离器分离效率的影响[J].流体机械,2014,42(3):6-9.ZHAO Lixin,WANG Yang,LUO Yajun,et al. The influence of overflow pipe structure on the separation efficiency of three-phase separator[J]. Fluid Machinery,2014,42(3):6-9.
[30] 赵立新,李宜强,徐保蕊,等.采出液脱气除砂一体化内锥式旋流器数值模拟[J].石油矿场机械,2015,44(1):1-5.ZHAO Lixin,LI Yiqiang,XU Baorui,et al. Numerical simulation of an integrated inner cone cyclone for degassing and sand removal of produced fluid[J]. Oil Field Equipment,2015,44(1):1-5.
[31] ZHAO Lixin,LI Yiqiang,XU Baorui,et al. Design and numerical simulation analysis of an integrative gas-liquid-solid separation hydrocyclone[J]. Chemical Engineering and Technology,2015,38(12):2146-2152.
[32] 赵立新,张淼,刘文庆,等.内锥式脱油旋流器流场分析与结构优化[J].化工机械,2011,38(2):202-205.ZHAO Lixin,ZHANG Miao,LIU Wenqing,et al. Flow field analysis and structure optimization of inner cone deoiling cyclone[J]. Chemical Engineering and Machinery,2011,38(2):202-205.
[33] XU Xiao,YANG Qiang,WANG Chaoyang,et al. Dissolved gas separation using the pressure drop and centrifugal characteristics of an inner cone hydrocyclone[J]. Separation and Purification Technology,2016,161:121-128.
[34] PARVAZ F,HOSSEINI S H,ELSAYED K,et al. Numerical investigation of effects of inner cone on flow field,performance and erosion rate of cyclone separators[J]. Separation and Purification Technology,2018,201:223-237.
[35] OBENG D P,MORRELL S. The JK three-product cyclone-performance and potential applications[J]. International Journal of Mineral Processing,2003,69(1-4):129-142.
[36] D·P·奥本,刘培坤,李长根. JK型三产品旋流器的性能特点及潜在的用途[J].国外金属矿选矿,2003,4(8):19-25.OBENG D P,LIU Peikun,LI Changgen. The performance characteristics and potential uses of the JK three-product cyclone[J]. Metallic Ore Dressing Abroad,2003,4(8):19-25.
[37] A·梅因扎,周廷熙,林森.三产品旋流器在双密度矿石分级中的应用[J].国外金属矿选矿,2004,4(12):28-33.MENINZA A,ZHOU Tingxi,LIN Sen. The application of three-product cyclones in the classification of dual-density ore[J]. Metallic Ore Dressing Abroad,2004,4(12):28-33.
[38] MAINZA A,POWELL M S,KNOPJES B. Differential classification of dense material in a three-product cyclone[J]. Minerals Engineering,2004,17(5):573-579.
[39] MAINZA A,NARASIMHA M,POWELL M S,et al. Study of flow behaviour in a three-product cyclone using computational fluid dynamics[J]. Minerals Engineering,2006,19(10):1048-1058.
[40] 陈波,杨兴华,刘培坤,等.双溢流管旋流器分离性能试验研究[J].轻金属,2018,4(5):9-13.CHEN Bo,YANG Xinghua,LIU Peikun,et al. Experimental study on separation performance of double overflow pipe cyclone[J]. Light Metals,2018,4(5):9-13.
[41] 刘培坤,赵雅琴,杨兴华,等.双溢流管旋流器分离性能的数值模拟与试验研究[J].煤矿机械,2020,41(2):40-43.LIU Peikun,ZHAO Yaqin,YANG Xinghua,et al. Numerical simulation and experimental research on the separation performance of double overflow pipe cyclones[J]. Coal Mine Machinery,2020,41(2):40-43.
[42] AHMED M M,IBRAHIM G A,FARGHALY M G. Performance of a three-product hydrocyclone[J]. International Journal of Mineral Processing,2009,91(1-2):34-40.
[43] SHOWALTER S,KOSTESKI EDWARD G. Three-phase cyclonic fluid separator:US,US007288138B2[P]. 2007-10-30.
[44] SHOWALTER S. Three-phase cyclonic fluid separator with a debris trap:US,US007288139B1[P]. 2007-10-30.
[45] ZHANG Yuekan,LIU Peikun,JIANG Lanyue,et al. The study on numerical simulation and experiments of four product hydrocyclone with double vortex finders[J]. Minerals,2019,9(1):23.
[46] YOSHIDA H,FUKUI K,PRATARN W,et al. Particle separation performance by use of electrical hydro-cyclone[J]. Separation and purification technology,2006,50(3):330-335.
[47] PRATARN W,WIWUT T,YOSHIDA H,et al. Effect of pH of fine silica suspension and central rod diameter on the cut size of an electrical hydrocyclone with and without underflow[J]. Separation and Purification Technology,2008,63(2):452-459.
[48] GONG Haifeng,YU Bao,DAI Fei,et al. Influence of electric field on water-droplet separated from emulsified oil in a double-field coupling device[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects,2018,550:27-36.
[49] GONG Haifeng,LI Wenlong,ZHANG Xianming,et al. Simulation of the coalescence and breakup of water-in-oil emulsion in a separation device strengthened by coupling electric and swirling centrifugal fields[J]. Separation and Purification Technology,2020,238:116397.
[50] LIU Lin,ZHAO Lixin,YANG Xu,et al. Innovative design and study of an oil-water coupling separation magnetic hydrocyclone[J]. Separation and Purification Technology,2019,213:389-400.
[51] MILLER J D. Apparatus and method for separating particles from a fluid suspension:US,US4397741A[P]. 1983-08-09.
[52] 余仁焕,李新国.利用充气旋流器净化含油污水的研究[J].矿冶,1996,5(3):94-99.YU Renhuan,LI Xinguo. Study on purification of oily wastewater with inflatable cyclone[J]. Mining and Metallurgy,1996,5(3):94-99.
[53] 潘利祥,孙国刚.充气水力旋流器用于油水分离的试验研究[J].化工机械,2004,31(5):259-263.PAN Lixiang,SUN Guogang. Experimental research on the application of aerated hydrocyclone for oil-water separation[J]. Chemical Engineering and Machinery,2004,31(5):259-263.
[54] 白志山,汪华林,裴世瑜,等.用于含油污水处理的气浮旋流耦合技术研究[J].环境污染治理技术与设备,2006,7(8):86-89.BAI Zhishan,WANG Hualin,PEI Shiyu,et al. Research on air flotation cyclone coupling technology for oily wastewater treatment[J]. Techniques and and Equipment for Environmental Pollution Control,2006,7(8):86-89.
[55] 赵立新,蒋明虎,刘书孟.微孔材料对气携式液-液水力旋流器性能的影响[J].石油机械,2006,4(10):5-7.ZHAO Lixin,JIANG Minghu,LIU Shumeng. The effect of microporous materials on the performance of gas-carried liquid-liquid hydrocyclones[J]. China Petroleum Machinery,2006,4(10):5-7.
[56] 赵立新,朱宝军,李枫,等.气携式液液水力旋流器分离性能影响因素[J].化学工程,2007,4(2):43-47.ZHAO Lixin,ZHU Baojun,LI Feng,et al. Influencing factors of separation performance of gas-carried liquid-liquid hydrocyclones[J]. Chemical Engineering,2007,4(2):43-47.
[57] ZHAO Lixin,JIANG Minghu,LI Feng. Experimental study on the separation performance of air-injected de-oil hydrocyclones[J]. Chemical Engineering Research and Design,2010,88(5-6):772-778.
[58] BARROZO M A S,DAMASCENO J J R,LANNA A E. Estudo do desempenho de um hidrociclone filtrante[J]. Revista Ciência and Engenharia,1992,1:175-186.BARROZO M A S,DAMASCENO J J R,LANNA A E. Performance study of a filtering hydrocyclone[J]. Science and Engineering Journal,1992,1:175-186.
[59] BRADLY D. The Hydrocyclone[M]. London:Pergamon Press,1965.
[60] RIETEMA K. Performance and design of hydrocyclones-IV:Design of hydrocyclones[J]. Chemical Engineering Science,1961,15(3-4):320-325.
[61] BARBOSA E A,VIEIRA L G M,ALMEIDA C A K,et al. Differences of behavior between filtering hydrocyclones with bradley and rietema geometry[J]. Material Science Forum,2003,416-418(1):317-322.
[62] VIEIRA L G M,BARBOSA E A,DAMASCENO J J R,et al. Performance analysis and design of filtering hydrocyclones[J]. Brazilian Journal of Chemical Engineering,2005,22(1):143-152.
[63] BARANOV D A,KUTEPOV A M,TSYGANOV L G. Filtering hydrocyclones[J]. Chemical and Petroleum Engineering,1997,33(6):619-623.
[64] GAUSTAD M,REICK R,SHAN W,et al. Crossflow filtration hydrocyclone for liquid/liquid separation[C]//Proceedings of the AIChE Annual Meeting. Nashville:Computing Systems and Technology Division,2009.
[65] 陈秀珍.天然气脱水用旋流过滤器结构优化及性能研究[D].青岛:中国石油大学(华东),2014.CHEN Xiuzhen. Structural optimization and performance research of cyclone filter for natural gas dehydration[D]. Qingdao:China University of Petroleum (East China),2014.
[66] 刘自强,刘锡荣,王振波,等.旋风过滤装置天然气脱水试验研究[J].过滤与分离,2015,25(4):10-13.LIU Ziqiang,LIU Xirong,WANG Zhenbo,et al. Experimental study on natural gas dehydration of cyclone filter device[J]. Filtration and Separation,2015,25(4):10-13.
[67] 张海军,张文平,翟路锁,等.旋流过滤器的研制与应用[J].煤炭科学技术,1997(11):29-30.ZHANG Haijun,ZHANG Wenping,ZHAI Lusuo,et al. Development and application of cyclone filter[J]. Coal Science and Technology,1997(11):29-30.
[68] 张文平,翟路锁.旋流过滤器:中国,90223327.0[P]. 1991-5-29.ZHANG Wenping,ZHAI Lusuo. Cyclone filter:China,90223327.0[P]. 1991-5-29.
[69] 张力,魏雷,常宝华,等.高含沙量黄河水滴灌泥沙分离系统研究[J].中国农村水利水电,2014(8):9-11,14.ZHANG Li,WEI Lei,CHANG Baohua,et al. Study on the separation system of drip irrigation in the yellow river with high sediment content[J]. China Rural Water and Hydropower,2014(8):9-11,14.
[70] TONIN P C,DANTAS NETO J,SANTOS J A A. Computer simulation of a Rietema-family hydrocyclone used in irrigated agriculture1[J]. Revista Ciência Agronômica,2015,46(1):38-47.
[71] SOCCOL O J,A BOTRE T. Hydrocyclone for pre-filtering of irrigation water[J]. Scientia Agricola,2004,61(2):134-140.
[72] YURDEM H,DEMIR V,A DEGIRMENCIOGLU. Development of a mathematical model to predict clean water head losses in hydrocyclone filters in drip irrigation systems using dimensional analysis[J]. Biosystems Engineering,2010,105(4):495-506.
[73] 王柏林,刘焕芳,刘贞姬,等.旋流网式组合型过滤器过滤性能研究[J].中国农村水利水电,2017(9):1-4,9.WANG Bolin,LIU Huanfang,LIU Zhenji,et al. Research on filtration performance of cyclone-net combined filter[J]. China Rural Water and Hydropower,2017(9):1-4,9.
[74] 刘达,黄本胜,邱静,等.一种螺旋式初期雨水过滤净化装置:中国,105089144A[P]. 2015-11-25.LIU Da,HUANG Bensheng,QIU Jing,et al. A spiral type initial rainwater filtration and purification device:China,105089144A[P]. 2015-11-25.
[75] 徐冉云.雨水旋流处理器的改进优化[J].中国给水排水,2016,32(24):44-48.XU Ranyun. Improvement and optimization of rainwater cyclone processor[J]. China Water and Wastewater,2016,32(24):44-48.
[76] 朱启德.旋流过滤器在油田集输中的实际应用[J].中国石油和化工标准与质量,2013,34(1):96.ZHU Qide. Practical application of cyclone filter in oilfield gathering and transportation[J]. China Petroleum and Chemical Standard and Quality,2013,34(1):96.
[77] 王武,邵建春.轻烃回收装置组合式旋风分离器的开发及改进[J].石油工程建设,2001,2:43-45.WANG Wu,SHAO Jianchun. Development and improvement of combined cyclone separator for light hydrocarbon recovery unit[J]. Petroleum Engineering Construction,2001,2:43-45.
[78] RODRIGUES M V,AROUCA F O,BARROZO M A S,et al. Analysis of the efficiency of a cloth cyclone:The effect of the permeability of the filtering medium[J]. Brazilian Journal of Chemical Engineering,2003,20(4):435-443.
[79] 蒋建忠.旋流分离器多功能化研究进展[J].流体机械,2004,4(11):29-31.JIANG Jianzhong. Research progress of multifunctional cyclone separator[J]. Fluid Machinery,2004,4(11):29-31.
[80] 任连城,梁政,梁利平,等.过滤式水力旋流器方案设计[J].西南石油学院学报,2005,27(1):82-85.REN Liancheng,LIANG Zheng,LIANG Liping,et al. Design of filter hydrocyclone scheme[J]. Journal of Southwest Petroleum University,2005,27(1):82-85.
[81] 应锐,喻俊志,王卫兵,等.细颗粒分级复合型水力旋流器结构及工艺参数的优化研究[J].机械工程学报,2017,53(2):124-134.YING Rui,YU Junzhi,WANG Weibing,et al. Optimization of structural and process parameters for fine particle classifying hydrocyclone[J]. Journal of Mechanical Engineering,2017,53(2):124-134.
[82] 杨云松. 300mm筛网旋流器及其应用[J].选煤技术,1989(2):9-16.YANG Yunsong. 300mm screen cyclone and its application[J]. Coal Preparation Technology,1989(2):9-16.
[83] 朱庆庆,杨建国,王兴兴.筛网旋流器透筛机理研究[J].煤矿机械,2011,32(8):38-40.ZHU Qingqing,YANG Jianguo,WANG Xingxing. Research on the mechanism of screen through cyclone[J]. Coal Mine Machinery,2011,32(8):38-40.
[84] 孔思蓉.三产品旋流分级筛柱段流场仿真研究[D].北京:中国矿业大学,2015.KONG Silong. Simulation study on the flow field of the three-product cyclone classification screen column[D]. Beijing:China University of Mining and Technology,2015.
[85] 李杉杉.倾斜筛网三产品旋流分级筛流场研究[D].北京:中国矿业大学,2019.LI Shanshan. Research on the flow field of the three-product cyclone grading screen with inclined screen[D]. Beijing:China University of Mining and Technology,2019.
[86] 黎涛.锥段筛网三产品旋流分级筛内部流场研究[D].北京:中国矿业大学,2019.LI Tao. Study on the internal flow field of the three-product cyclone grading screen of the cone screen[D]. Beijing:China University of Mining and Technology,2019.
[87] 刘雯,程小莉,陈勇,等.管内螺旋导流板引发的气液两相旋流场[J].机械工程学报,2013,49(22):164-169.LIU Wen,CHENG Xiaoli,CHEN Yong,et al. Gas-liquid swirling flow induced by helical tape with core-rod inside circular pipe[J]. Journal of Mechanical Engineering,2013,49(22):164-169.
[88] 徐冉云.一种雨水旋流过滤器:中国,105999808A[P]. 2016-10-12.XU Ranyun. A rainwater cyclone filter:China,105999808A[P]. 2016-10-12.
[89] LIN J Y,WU R M. Three output membrane hydrocyclone:Classification and filtration[J]. Molecules,2019,24(6):1116.
[90] 罗金耀,邱元锋.水力旋流过滤器:中国,201643871U[P]. 2010-11-2.LUO Jinyao,QIU Yuanfeng. Hydrocyclone filter:China,201643871U[P]. 2010-11-2.
[91] 李建平,何相逸,陈骏炀,等.养殖水颗粒物处理装置:中国,107721119A[P]. 2018-02-23.LI Jianping,HE Xiangyi,CHEN Junyang,et al. Aquaculture water particulate matter treatment device:China,107721119A[P]. 2018-02-23.
[92] 许元敏,徐琳,黄丽华,等.旋流过滤器:中国,110002620[P]. 2019-07-12.XU Yuanmin,XU Lin,HUANG Lihua,et al. Cyclone filter:China,110002620[P]. 2019-07-12.
[93] 张力,张立华,徐光亿,等.新型旋流分离一体机的分离性能分析[J].兰州理工大学学报,2020,46(1):60-64.ZHANG Li,ZHANG Lihua,XU Guangyi,et al. Separation performance analysis of a new type of cyclone separator[J]. Journal of Lanzhou University of Technology,2020,46(1):60-64.
[94] 梅振清,罗永焕,杜文志,等.一种抽网式旋流过滤器:中国,207591382U[P]. 2018-07-10.MEI Zhenqing,LUO Yonghuan,DU Wenzhi,et al. A type of cyclone filter with net extraction:China,207591382U[P]. 2018-07-10.
[95] 刘旭洋,周淑文.内嵌滤筒结构气固旋流分离器除尘的数值模拟[J].当代化工,2018,47(11):2453-2456.LIU Xuyang,ZHOU Shuwen. Numerical simulation of dust removal in a gas-solid cyclone separator with a built-in filter cartridge[J]. Contemporary Chemical Industry,2018,47(11):2453-2456.
[96] 詹向东,沈逸夫,瞿卫,等.旋流式精密过滤器:中国,208389794U[P]. 2019-01-18.ZHAN Xiangdong,SHEN Yifu,QU Wei,et al. Swirl precision filter:China,208389794U[P]. 2019-01-18.
[97] 孙凤玲,于传龙.利用旋液分离过滤器净化混合油的优越性[J].黑龙江粮食,2003,3:45.SUN Fengling,YU Chuanlong. The superiority of using hydrocyclone filter to purify mixed oil[J]. Heilongjiang Grain,2003,3:45.
[98] ZHANG Zhen,WANG Hua,MA Jie,et al. Numerical study on a novel type of high gravity rotary gas-liquid separator[J]. Journal of Applied Fluid Mechanics,2020,13(3):969-979.
[99] BROWN R C,SHI H,COLVER G,et al. Similitude study of a moving bed granular filter[J]. Powder technology,2003,138(2-3):201-210.
[100] EL-HEDOK I A,WHITMER L,BROWN R C. The influence of granular flow rate on the performance of a moving bed granular filter[J]. Powder Technology,2011,214(1):69-76.
[101] YOU Minghao,LI Zhaoyang,ZHAN Minshu,et al. Flow simulation and performance analysis of a cyclone-granular bed filter[J]. Powder Technology,2020,361:210-219.
[102] 高思鸿,张丹丹,范怡平,等.气体干法净化旋流吸附耦合设备压降特性[J].化工学报,2018,69(5):1873-1883.GAO Sihong,ZHANG Dandan,FAN Yiping,et al. Pressure drop characteristics of dry gas purification cyclone adsorption coupling equipment[J]. CIESC Journal,2018,69(5):1873-1883.
[103] GAO Sihong,ZHANG Dandan,FAN Yiping,et al. Separation performance in a novel coupled cyclone with built-in circulating granular bed filter (C-CGBF)[J]. Industrial and Engineering Chemistry Research,2018,57(36):12192-12201.
[104] GAO Sihong,ZHANG Dandan,FAN Yiping,et al. A novel gas-solids separator scheme of coupling cyclone with circulating granular bed filter (C-CGBF)[J]. Journal of Hazardous Materials,2019,362:403-411.
[105] 高思鸿,刘堉学,范怡平,等.新型旋流场-颗粒床耦合分离设备静压分布[J].化工学报,2020,71(2):516-525.GAO Sihong,LIU Yuxue,FAN Yiping,et al. Static pressure distribution of a new type of cyclone field-particle bed coupling separation equipment[J]. CIESC Journal,2020,71(2):516-525.
[106] NEMCHENKO A G,NEMCHENKO A A,SIDOROV V A,et al. Device for purification of sewage and other liquids:Russia,2069102C1-2069103C1[P]. 1996-11-20.
[107] 卢继霞,郭瑞宇,王成,等.基于固体颗粒尺寸分布的微孔滤膜堵塞机理分析[J].机械工程学报,2018,54(20):145-151.LU Jixia,GUO Ruiyu,WANG Cheng,et al. Fouling mechanism analysis on micro-pore filter membrane based on the solid particle size distribution[J]. Journal of Mechanical Engineering,2018,54(20):145-151.
[108] INST L,KAELTETECH G. Kombinierter abscheider:Germany,29709879U1[P]. 1997-06-06.
[109] 沈丽娟,陈建中,何丽君,等.一种三产品旋流分级筛:中国,201020108608.3[P]. 2010-11-24.SHEN Lijuan,CHEN Jianzhong,HE Lijun,et al. A three-product cyclical flow classification screen:China,201020108608.3[P]. 2010-11-24.
[110] 王和鹏. PKN-Ⅳ型糖浆旋流过滤器的应用[J].中国甜菜糖业,2005(3):50-51.WANG Hepeng. PKN-Ⅳ syrup spiral flow filter application[J]. China Beet&Sugar,2005(3):50-51.
[111] 方为茂,钟本和,张充湘.旋流分离设备新结构进展[J].化工装备技术,1998(4):47-52.FANG Weimao,ZHONG Benhe,ZHANG Chongxiang. Advances in the new structure of cyclonic separation equipment[J]. Chemical Equipment Technology,1998(4):47-52.
[112] 袁东立.旋流过滤双效净水器:中国,96241694.0[P]. 1997-11-26.YUAN Dongli. Cyclonic filter dual-effect water purifier:China,96241694.0[P].1997-11-26.
[113] 成云.旋转填料床中两相流动力学模型及其试验研究[D].北京:北京工业大学,2013.CHENG Yun. Mechanical Model and experimental study of two-phase flow in rotating packing bed[D]. Beijing:Beijing University of Technology,2013.
[114] OLIVEIRA D C,PIRES L N,VIEIRA L G M,et al. Prediction of performance of a hydrocyclone with filtering cylinder[J]. Materials Science Forum,2010,660-661:525-530.
[115] MOTIN A,GAUSTAD M D,TARABARA V V,et al. Simulations and performance of the crossflow filtration hydrocyclone (CFFH) for oil-water separation[C]//ASME 2013 Fluids Engineering Division Summer Meeting,Nevada:American Society of Mechanical Engineers,2013,FEDSM2013-16195,V01CT18A004.
[116] MOTIN A,TARABARA V V,BÉNARD A. CFD study of hydrodynamics and separation performance of a novel crossflow filtration hydrocyclone (CFFH)[C]//ASME 20144th Joint US-European Fluids Engineering Division Summer Meeting collocated with the ASME 201412th International Conference on Nanochannels,Microchannels,and Minichannels. Chicago:American Society of Mechanical Engineers Digital Collection,2014,FEDSM2014-21289,V01CT16A008.
[117] SOUZA F J,VIEIRA L G M,DAMASCENO J J R,et al. Analysis of the influence of the filtering medium on the behaviour of the filtering hydrocyclone[J]. Powder Technology,2000,107(3):259-267.
[118] VIEIRA L G M,DAMASCENO J J R,BARROZO M A S. Filtration on hydrocyclone of optimized geometric relationships[J]. Materials Science Forum,2008,591-593:341-346.
[119] 黎国华,聂文平.过滤式水力旋流器开发与研究[J].科技创业月刊,2004,4:20.LI Guohua,NIE Wenping. Development and research of filter hydrocyclone[J]. Pioneering With Science and Technology Monthly,2004,4:20.
[120] VIEIRA L G M,SILVA JR C A,DAMASCENO J J R,et al. A study of the fluid dynamic behaviour of filtering hydrocyclones[J]. Separation and purification Technology,2007,58(2):282-287.
[121] BARBOSA E A,VIEIRA L G M,ALVES M C,et al. Behavior of a filtering hydrocyclone of CBV Demco's geometry[C]//Proceedings of the Fourth International Latin-American Conference on Powder Technology,Guarujá:Trans. Tech. Publications Ltd., 2003.
[122] 刘仁桓.旋流过滤器分离机理研究[D].青岛:中国石油大学(华东),2011.LIU Renhuan. Study on the separation mechanism of cyclone filter[D]. Qingdao:China University of Petroleum (East China),2011.
[123] 刘仁桓,王振波,杨晓惠,等.新型旋流过滤组合式分离器:中国,200620176018.8[P]. 2007-12-12.LIU Renhuan,WANG Zhenbo,YANG Xiaohui,et al. New type cyclone filter combined separator:China,200620176018.8[P]. 2007-12-12.
[124] 刘书孟,董喜贵,赵雪峰.旋转流微孔过滤器:中国,1958114[P]. 2007-05-09.LIU Shumeng,DONG Xigui,ZHAO Xuefeng. Rotating flow microporous filter:China,1958114[P]. 2007-05-09.
[125] 赵立新,徐磊,陈世琢,等.尾管过滤式水力旋流器滤出效率试验研究[J].化工机械,2008(5):267-270.ZHAO Lixin,XU Lei,CHEN Shizhuo,et al. Experimental study on filtration efficiency of tailpipe filter hydrocyclone[J]. Chemical Engineering and Machinery,2008(5):267-270.
[126] 李京瑞.错流过滤式水力旋流器的结构优化及性能研究[D].北京:北京化工大学,2018.LI Jingrui. Structure optimization and performance research of cross-flow filter hydrocyclone[D]. Beijing:Beijing University of Chemical Technology,2018.
[127] 姚宇婷,茅陆荣.一种Y型旋流过滤器:中国,103567087A[P]. 2014-02-12.YAO Yuting,MAO Lurong. A Y-shaped cyclone filter:China,103567087A[P]. 2014-02-12.
[128] WANG C C,WU R M. Experimental and simulation of a novel hydrocyclone-tubular membrane as overflow pipe[J]. Separation and Purification Technology,2018,198:60-67.
[129] 刘铁航,袁惠新,羊衍贵.水力旋流筛分机设计方案探讨[J].洁净煤技术,2006(1):79-81.LIU Tiehang,YUAN Huixin,YANG Yangui. Discussion on the Design Scheme of Hydrocyclone Screening Machine[J]. Clean Coal Technology,2006(1):79-81.
[130] 刘铁航,袁惠新.旋流式筛分过程初探[J].粉末冶金工业,2006,16(2):27-30.LIU Tiehang,YUAN Huixin. Preliminary study on the cyclone screening process[J]. Powder Metallurgy Industry,2006,16(2):27-30.
[131] SALVADOR F F,BARROZO M A S,VIEIRA L G M. Effect of a cylindrical permeable wall on the performance of hydrocyclones[J]. Chemical Engineering&Technology,2016,39(6):1015-1022.
[132] FACANHA J M F,SILVA D O,BARROZO M A S,et al. Analysis of the use of a filtering medium in different parts of a centrifugal separator[C]//Materials Science Forum. Trans Tech Publications Ltd. 2012,727:20-25.
[133] 杨晓惠,刘仁桓,金有海.旋流过滤器的结构与性能研究[J].流体机械,2008(5):10-13.YANG Xiaohui,LIU Renhuan,JIN Youhai. Research on the structure and performance of cyclone filter[J]. Fluid Machinery,2008(5):10-13.
[134] 王云峰.旋流过滤器内部液固两相流场模拟研究[D].青岛:中国石油大学(华东),2013.WANG Yunfeng. Simulation study on the liquid-solid two-phase flow field inside the cyclone filter[D]. Qingdao:China University of Petroleum (East China),2013.
[135] VIEIRA L G M,SILVA D O,BARROZO M A S. Study of the performance of a novel hydrocyclone built in the configurations of the classical families[J]. Separation Science and Technology,2013,48(17):2700-2706.
[136] AZEVEDO R,VELOSO C O,MEDRONHO R A. Performance dehidrociclones cbv-demco 4h[C]//Proceedings of the XXII Brazilian Congress on Particulate Systems. Friburgo,Brazil. 1990:481-488.
[137] VIEIRA L G M,SILVÉRIO B C,DAMASCENO J J R,et al. Performance of hydrocyclones with different geometries[J]. The Canadian Journal of Chemical Engineering,2011,89(4):655-662.
[138] VIEIRA L G M,DAMASCENO J J R,BARROZO M A S. Improvement of hydrocyclone separation performance by incorporating a conical filtering wall[J]. Chemical Engineering and Processing:Process Intensification,2010,49(5):460-467.
[139] SILVA D O,VIEIRA L G M,LOBATO F S,et al. Optimization of the design and performance of hydrocyclones by Differential Evolution technique[J]. Chemical Engineering and Processing:Process Intensification,2012,61:1-7.
[140] BOX G E P,HUNTER W G,HUNTER J S. Statistics for experimenters:An Introduction to design,data analysis and model building[M]. New York:John Wiley and Sons,1978.
[141] STORN R,K PRICE. Differential evolution a simple evolution strategy for fast optimization[J]. Dr Dobb's Journal,1997,22(4):18-24.
[142] SILVA D O,VIEIRA L G M,LOBATO F S,et al. Optimization of hydrocyclone performance using multi-objective firefly colony algorithm[J]. Separation Science and Technology,2013,48(12):1891-1899.
[143] SILVA D O,VIEIRA L G M,BARROZO M A S. Optimization of design and performance of solid-liquid separators:A thickener hydrocyclone[J]. Chemical Engineering and Technology,2015,38(2):319-326.
[144] SALVADOR F F,BARROZO M A S,VIEIRA L G M. Filtering cylindrical-conical hydrocyclone[J]. Particuology,2019,47:54-62.
[145] GARCIA V A,LOBATO F S,VIEIRA L G M. Design of high performance thickener hydrocyclones using robust optimization[J]. Journal of Petroleum Science and Engineering,2020,191:107144.
[146] SALVADOR F F,ASCENDINO G G,FARIAÉ V,et al. Geometric optimization of filtering cylindrical hydrocyclones[J]. Powder Technology,2021,381:611-619.
[147] BRADLEY D,PULLING D J. Flow patterns in the hydraulic cyclone and their interpretation in terms of performance[J]. Transactions of the Institution of Chemical Engineers,1959,37:34-45.
[148] VIEIRA L G M. Otimização dos Processos de Separação em hidrociclones Filtrantes[D]. Uberlândia:Universidade Federal de Uberlândia,2006. VIEIRA L G M. Optimization of separation processes in filter hydrocyclones[D]. Uberlândia:Federal University of Uberlândia,2006.
[149] VIEIRA L G M,DAMASCENO J J R,BARROZO M A S. Computational fluid dynamics applied to bradley hydrocyclones[C]//Materials science forum Trans Tech Publications Ltd. 2006,530:376-381.
[150] OLIVEIRA D C,ALMEIDA C A K,VIEIRA L G M,et al. Influence of geometric dimensions on the performance of a filtering hydrocyclone:an experimental and CFD study[J]. Brazilian Journal of Chemical Engineering,2009,26(3):575-582.
[151] SILVA N K G,SALVADOR F F,VIEIRA L G M,et al. Analysis of the effect of the underflow orifice size on the filtering and concentrating hydrocyclone[C]//Materials Science Forum. Trans Tech Publications Ltd. 2014,802:245-249.
[152] VIEIRA L G M,BARROZO M A S. Effect of vortex finder diameter on the performance of a novel hydrocyclone separator[J]. Minerals Engineering,2014,57:50-56.
[153] SILVA N K G,SILVA D O,VIEIRA L G M,et al. Effects of underflow diameter and vortex finder length on the performance of a newly designed filtering hydrocyclone[J]. Powder Technology,2015,286:305-310.
[154] VIEIRA L G M,SILVA D O,BARROZO M A S. Effect of inlet diameter on the performance of a filtering hydrocyclone separator[J]. Chemical Engineering&Technology,2016,39(8):1406-1412.
[155] GONÇALVES S M,BARROZO M A S,VIEIRA L G M. Effects of solids concentration and underflow diameter on the performance of a newly designed hydrocyclone[J]. Chemical Engineering&Technology,2017,40(10):1750-1757.
[156] 蒋明虎,周定,贺杰.水力旋流器压力损失的综合试验研究[J].石油机械,1999(11):18-20. JIANG Minghu,ZHOU Ding,HE Jie. Comprehensive experimental research on hydrocyclone pressure loss[J]. China Petroleum Machinery,1999(11):18-20.
[157] TANG Bo,XU Yanxia,SONG Xingfu,et al. Effect of inlet configuration on hydrocyclone performance[J]. Transactions of Nonferrous Metals Society of China,2017,27(7):1645-1655.
[158] LAMSKOVA M,FILIMONOV M,NOVIKOV A,et al. Modeling of the separation for system the liquid-solid in the battery of hydrocyclones[C]//Journal of Physics:Conference Series IOP Publishing,2019,1278(1):012011.
[159] AL-KAYIEM H H,OSEI H,HASHIM F M,et al. Flow structures and their impact on single and dual inlets hydrocyclone performance for oil-water separation[J]. Journal of Petroleum Exploration and Production Technology,2019,9(4):2943-2952.
[160] HWANG K J,HWANG Y W,YOSHIDA H. Design of novel hydrocyclone for improving fine particle separation using computational fluid dynamics[J]. Chemical Engineering Science,2013,85:62-68.
[161] 谢知峻.粒子排布器对旋流过滤器分离性能强化的数值模拟[D].青岛:中国石油大学(华东),2015. XIE Zhijun. Numerical simulation of the enhancement of the separation performance of the cyclone filter by the particle arrangement[D]. Qingdao:China University of Petroleum (East China),2015.
[162] 蒋明虎,赵立新,李枫,等.液-液水力旋流器的入口形式及其研究[J].石油矿场机械,1998,(2):7-10,12. JIANG Minghu,ZHAO Lixin,LI Feng,et al. The inlet form of the liquid-liquid hydrocyclone and its research[J]. Oil Field Equipment,1998,(2):7-10,12.
[163] ZHANG L,WEI L,CHANG B H,et al. CFD numerical simulation of Archimedes spiral inlet hydrocyclone[C]//IOP Conference Series:Materials Science and Engineering. IOP Publishing. 2013,52(7):072021-072027.
[164] RAZMI H,GOHARRIZI A S,MOHEBBI A. CFD simulation of an industrial hydrocyclone based on multiphase particle in cell (MPPIC) method[J]. Separation and Purification Technology,2019,209:851-862.
[165] 王圆,赵立新,王月文,等.不同入口形式油水分离旋流器数值模拟的对比分析[J].流体机械,2017,45(7):22-27. WANG Yuan,ZHAO Lixin,WANG Yuewen,et al. Comparative analysis of numerical simulation of oil-water separation cyclones with different inlets[J]. Fluid Machinery,2017,45(7):22-27.
[166] ZHANG Caie,WEI Dezhou,CUI Baoyu,et al. Effects of curvature radius on separation behaviors of the hydrocyclone with a tangent-circle inlet[J]. Powder Technology,2017,305:156-165.
[167] 赵立新,刘丽丽,徐磊,等.倾斜入口流道的水力旋流器数值模拟分析[J].化工机械,2012,39(2):203-205. ZHAO Lixin,LIU Lili,XU Lei,et al. Numerical simulation analysis of hydrocyclone with inclined inlet flow channel[J]. Chemical Engineering&Machinery,2012,39(2):203-205.
[168] 孙越高,陈启东.组合式旋流器处理污水的数值分析[J].过程工程学报,2017,17(3):477-483. SUN Yugao,CHEN Qidong. Numerical analysis of combined hydrocyclone for wastewater treatment[J]. The Chinese Journal of Process Engineering,2017,17(3):477-483.
[169] GHODRAT M,KUANG S B,YU A B,et al. Computational study of the multiphase flow and performance of hydrocyclones:Effects of cyclone size and spigot diameter[J]. Industrial and Engineering Chemistry Research,2013,52(45):16019-16031.
[170] KIM J O,CHOI J,LEE S,et al. Evaluation of hydrocyclone and post-treatment technologies for remediation of contaminated dredged sediments[J]. Journal of Environmental Management,2016,166:94-102.
[171] XIANG R B,LEE K W. Numerical study of flow field in cyclones of different height[J]. Chemical Engineering and Processing:Process Intensification,2005,44(8):877-883.
[172] WANG Liyang,ZHENG Zhichun,WU Yingxiang,et al. Numerical and experimental study on liquid-solid flow in a hydrocyclone[J]. Journal of Hydrodynamics,2009,21(3):408-414.
[173] 刘培坤,王鹤,杨兴华,等.球柱形旋风除尘器分离性能数值模拟与试验[J].环境工程学报,2019,13(9):2189-2197. LIU Peikun,WANG He,YANG Xinghua,et al. Numerical simulation and experiment on the separation performance of spherical cylindrical cyclone dust collector[J]. Chinese Journal of Environmental Engineering,2019,13(9):2189-2197.
[174] 杨晓惠.旋流过滤器结构优化设计及性能研究[D].青岛:中国石油大学(华东),2008. YANG Xiaohui. Structural optimization design and performance research of cyclone filter[D]. Qingdao:China University of Petroleum (East China),2008.
[175] 盛文君.基于神经网络的旋流过滤器性能分析[D].青岛:中国石油大学(华东),2016. SHENG Wenjun. Performance analysis of cyclone filter based on neural network[D]. Qingdao:China University of Petroleum (East China),2016.
[176] 宋辉智.溢流管插入深度及圆柱段高度对旋流式过滤器沉沙效果的影响[D].呼和浩特:内蒙古农业大学,2012. SONG Huizhi. The influence of the insertion depth of the overflow pipe and the height of the cylindrical section on the sedimentation effect of the cyclone filter[D]. Hohhot:Inner Mongolia Agricultural University,2012.
[177] HWANG K J,HWANG Y W,YOSHIDA H,et al. Improvement of particle separation efficiency by installing conical top-plate in hydrocyclone[J]. Powder Technology,2012,232:41-48.
[178] XU Xiao,YANG Qiang,WANG Chaoyang,et al. Impact of bubble coalescence on separation performance of a degassing hydrocyclone[J]. Separation and Purification Technology,2015,152:80-86.
[179] JUNG K J,HWANG I J,KIM Y J. Effect of inner wall configurations on the separation efficiency of hydrocyclone[J]. Journal of Mechanical Science and Technology,2019,33(11):5277-5283.
[180] NOROOZI S,HASHEMABADI S H. CFD analysis of inlet chamber body profile effects on de-oiling hydrocyclone efficiency[J]. Chemical Engineering Research and Design,2011,89(7):968-977.
[181] YANG Xinghua,SIMMONS M J H,LIU Peikun,et al. Effect of feed body geometry on separation performance of hydrocyclone[J]. Separation Science and Technology,2019,54(17):2959-2970.
[182] TANG Bo,XU Yanxia,SONG Xingfu,et al. Numerical study on the relationship between high sharpness and configurations of the vortex finder of a hydrocyclone by central composite design[J]. Chemical Engineering Journal,2015,278:504-516.
[183] 袁惠新,李丽丽,杨振东,等.溢流口结构对旋流器溢流分率影响的模拟及试验研究[J].煤矿机械,2010,31(1):67-70. YUAN Huixin,LI Lili,YANG Zhendong,et al. Simulation and experimental research on the influence of overflow structure on cyclone overflow fraction[J]. Coal Mining Machinery,2010,31(1):67-70.
[184] GHODRAT M,KUANG S B,YU A B,et al. Numerical analysis of hydrocyclones with different vortex finder configurations[J]. Minerals Engineering,2014,63:125-138.
[185] 刘鸿雁,王亚,韩天龙,等.水力旋流器溢流管结构对微细颗粒分离的影响[J].化工学报,2017,68(5):1921-1931. LIU Hongyan,WANG Ya,HAN Tianlong,et al. The influence of hydrocyclone overflow tube structure on the separation of fine particles[J]. CIESC Journal,2017,68(5):1921-1931.
[186] 黄军,安连锁.溢流口结构对石膏旋流器分离性能的影响[J].动力工程学报,2011,31(2):137-141. HUANG Jun,AN Liansuo. Influence of overflow structure on separation performance of gypsum cyclone[J]. Journal of Chinese Society of Power Engineering,2011,31(2):137-141.
[187] TIAN Jinyi,NI Long,SONG Tao,et al. CFD simulation of hydrocyclone-separation performance influenced by reflux device and different vortex-finder lengths[J]. Separation and Purification Technology,2020,233:116013.
[188] 赵立新,钟声,赵雪峰,等.新型多孔溢流管式旋流器的结构模拟分析[J].石油机械,2012,40(3):62-66. ZHAO Lixin,ZHONG Sheng,ZHAO Xuefeng,et al. Structural simulation analysis of a new type of porous overflow pipe cyclone[J]. China Petroleum Machinery,2012,40(3):62-66.
[189] 田金乙,倪龙,赵加宁.污水旋流防阻机在不同溢流管与圆柱段长度比值下的分离性能试验[J].高校化学工程学报,2017(1):31-37. TIAN Jinyi,NI Long,ZHAO Jianing. Separation performance test of sewage cyclone anti-blocking machine under different ratios of overflow pipe and cylindrical section length[J]. Journal of Chemical Engineering of Chinese Universities,2017(1):31-37.
[190] JIANG Lanyue,LIU Peikun,YANG Xinghua,et al. Short-circuit flow in hydrocyclones with arc-shaped vortex finders[J]. Chemical Engineering and Technology,2018,41(9):1783-1792.
[191] VAKAMALLA T R,KORUPROLU V B R,ARUGONDA R,et al. Development of novel hydrocyclone designs for improved fines classification using multiphase CFD model[J]. Separation and Purification Technology,2017,175:481-497.
[192] 应锐,王卫兵,冯静安,等.溢流管外壁环形齿对旋流器的影响分析[J].煤矿机械,2015,36(1):126-128. YING Rui,WANG Weibing,FENG Jingan,et al. Analysis of the influence of the annular teeth on the outer wall of the overflow pipe on the cyclone[J]. Coal Mining Machinery,2015,36(1):126-128.
[193] GHODRAT M,KUANG S B,YU A B,et al. Numerical analysis of hydrocyclones with different conical section designs[J]. Minerals Engineering,2014,62:74-84.
[194] MOTIN A,BÉNARD A. Design of liquid-liquid separation hydrocyclones using parabolic and hyperbolic swirl chambers for efficiency enhancement[J]. Chemical Engineering Research and Design,2017,122:184-197.
[195] 赵立新,李枫,王尊策,等.液液水力旋流器流场特性与分离特性研究(二)——锥角变化对轴向速度场的影响[J].化工装备技术,1999(5):1-3. ZHAO Lixin,LI Feng,WANG Zunce,et al. Research on flow field characteristics and separation characteristics of liquid-liquid hydrocyclones (2)-The effect of cone angle change on axial velocity field[J]. Chemical Equipment Technology,1999(5):1-3.
[196] 蒋明虎,王尊策,李枫,等.结构及操作参数对旋流器切向速度场的影响——液-液水力旋流器速度场研究之二[J].石油机械,1999(2):20-22. JIANG Minghu,WANG Zunce,LI Feng,et al. The influence of structure and operating parameters on the tangential velocity field of a cyclone:Study on the velocity field of a liquid-liquid hydrocyclone[J]. China Petroleum Machinery,1999(2):20-22.
[197] YANG Qiang,WANG Hualin,LIU Yi,et al. Solid/liquid separation performance of hydrocyclones with different cone combinations[J]. Separation and Purification Technology,2010,74(3):271-279.
[198] YE Junxiang,XU Yanxia,SONG Xingfu,et al. Novel conical section design for ultra-fine particles classification by a hydrocyclone[J]. Chemical Engineering Research and Design,2019,144:135-149.
[199] YOSHIDA H,HAYASE Y,FUKUI K,et al. Effect of conical length on separation performance of sub-micron particles by electrical hydro-cyclone[J]. Powder Technology,2012,219:29-36.
[200] 胡言凤.底流口直径对筛网旋流器分级效果的影响[J].选煤技术,2015(3):17-20,25. HU Yanfeng. The influence of the diameter of the underflow opening on the classification effect of the screen cyclone[J]. Coal Preparation Technology,2015(3):17-20,25.
[201] 胡言凤.筛网旋流器试验样机的设计[J].煤炭加工与综合利用,2016(5):22-24,27. HU Yanfeng. Design of the test prototype of the screen cyclone[J]. Coal Processing and Comprehensive Utilization,2016(5):22-24,27.
[202] 田金乙,倪龙,赵加宁.底流管直径对旋流防阻机性能的影响[J].化工学报,2016,67(10):4219-4224. TIAN Jinyi,NI Long,ZHAO Jianing. The influence of the diameter of the underflow tube on the performance of the cyclone anti-blocking machine[J]. CIESC Journal,2016,67(10):4219-4224.
[203] NI Long,TIAN Jinyi,ZHAO Jianing. Experimental study of the effect of underflow pipe diameter on separation performance of a novel de-foulant hydrocyclone with continuous underflow and reflux function[J]. Separation and Purification Technology,2016,171:270-279.
[204] 刘焕芳,王军,胡九英,等.旋流网式过滤器水力性能的试验研究[C]//人水和谐及新疆水资源可持续利用——中国科协2005学术年会论文集. 2005:426-430. LIU Huanfang WANG Jun,HU Jiuying,et al. Experimental study on hydraulic performance of a hydrocyclonic strainer-type filter[C]//Harmony between Man and Water and Sustainable Utilization of Water Resources in Xinjiang-Proceedings of the 2005 Academic Annual Meeting of China Association for Science and Technology. 2005:426-430.
[205] LAPPLE C E. Dust and mist collection[J]. Chemical Engineering Handbook,1950,3:1013-1050.
[206] MASSARNI G. Projeto e análise do desempenho de ciclones e hidrociclones II[C]//Proceedings of the XVII Encontro Nacional sobre Escoamento em Meios Porosos. São Carlos Brazilian Society for Particulate Systems 1989,125-136. MASSARANI G. Design and performance analysis of cyclones and hydrocyclones II[C]//XVII National Meeting on Flow in Porous Media. San Carlos:1989, 125-136.
[207] 赵传伟,李增亮,邓良驹,等.井下双级串联式油水分离器工作特性研究[J].机械工程学报,2014,50(18):177-185. ZHAO Chuanwei,LI Zengliang,DENG Liangju,et al. Research on operating characteristic of downhole dual-stage tandem oil-water separator[J]. Journal of Mechanical Engineering,2014,50(18):177-185.
[208] 王建,王丽娟,王伟,等.旋流过滤器除砂效果试验模拟研究[J].内蒙古石油化工,2019,45(5):121-124. WANG Jian,WANG Lijuan,WANG Wei,et al. Experimental simulation study on de-sanding effect of cyclone filter[J]. Inner Mongolia Petrochemical Industry,2019,45(5):121-124.
[209] 韩柏,王云峰,盛文君,等.旋流过滤器分离效率的数值模拟结果分析[J].中国粉体技术,2014,20(1):71-74. HAN Bai,WANG Yunfeng,SHENG Wenjun,et al. Analysis of numerical simulation results of separation efficiency of cyclone filter[J]. China Powder Science and Technology,2014,20(1):71-74.
[210] ZHAO Lixin,JIANG Minghu,WANG Yue. Experimental study of a hydrocyclone under cyclic flow conditions for fine particle separation[J]. Separation and Purification Technology,2008,59(2):183-189.
[211] JIANG Minghu,ZHAO Lixin,HE Jie,et al. Pressure drop ratio-an important performance parameter in liquid-liquid hydrocyclone separation[C]//The Eighth International Offshore and Polar Engineering Conference. Montreal:International Society of Offshore and Polar Engineers,1998,2:335-337.
[212] TIAN Jinyi,WANG Hualin,LV Wenjie,et al. Enhancement of pollutants hydrocyclone separation by adjusting back pressure ratio and pressure drop ratio[J]. Separation and Purification Technology,2020,240:116604.
[213] GHODRAT M,QI Z,KUANG S B,et al. Computational investigation of the effect of particle density on the multiphase flows and performance of hydrocyclone[J]. Minerals Engineering,2016,90:55-69.
[214] SABBAGH R,KOCH C R,LIPSETT M G,et al. Hydrocyclone equivalent settling area factor at higher concentrations and developing a performance chart[J]. Separation and Purification Technology,2017,182:171-184.
[215] 徐保蕊,蒋明虎,张晓光,等.采出液中固相颗粒对三相分离器性能的影响[J].中国粉体技术,2016,22(3):5-12. XU Baorui,JIANG Minghu,ZHANG Xiaoguang,et al. The effect of solid particles in produced liquid on the performance of three-phase separator[J]. China Powder Science and Technology,2016,22(3):5-12.
[216] 王志斌,陈文梅,褚良银,等.旋流分离器中固体颗粒随机轨道的数值模拟及分离特性分析[J].机械工程学报,2006,4(6):34-39. WANG Zhibin,CHEN Wenmei,CHU Liangyin,et al. Numerical simulstion of particale motion trjectory in a hudrocyclone using a stochastic trajectory model[J]. Journal of Mechanical Engineering,2006,4(6):34-39.
[217] CUI Rui,WANG Guanghui,LI Maolin. Size dependent flow behaviors of particles in hydrocyclone based on multiphase simulation[J]. Transactions of Nonferrous Metals Society of China,2015,25(7):2422-2428.
[218] 苏劲,袁智,侍玉苗,等.水力旋流器细粒分离效率优化与数值模拟[J].机械工程学报,2011,47(20):183-190. SU Jin,YUAN Zhi,SHI Yumiao,et al. Separation efficiency optimization of liquid-solid hydrocyclone and numerical simulation[J]. Journal of Mechanical Engineering,2011,47(20):183-190.
[219] TANG Zhaojia,YU Liming,WANG Fenghua,et al. Effect of particle size and shape on separation in a hydrocyclone[J]. Water,2019,11(1):16.
[220] KASHIWAYA K,NOUMACHI T,HIROYOSHI N,et al. Effect of particle shape on hydrocyclone classification[J]. Powder technology,2012,226:147-156.
[221] MURTHY Y R,BHASKAR K U. Parametric CFD studies on hydrocyclone[J]. Powder Technology,2012,230:36-47.
[222] 赵立新,蒋明虎,李枫,等.结构及操作参数对旋流器轴向速度场的影响——液-液水力旋流器速度场研究之四[J].石油机械,1999(4):15-17. ZHAO Lixin,JIANG Minghu,LI Feng,et al. The influence of structure and operating parameters on the axial velocity field of a cyclone——the fourth study on the velocity field of liquid-liquid hydrocyclones[J]. China Petroleum Machinery,1999(4):15-17.
[223] 蒋明虎.旋流分离技术研究及其应用[J].大庆石油学院学报,2010,34(5):101-109,171. JIANG Minghu. Research and application of cyclone separation technology[J]. Journal of Daqing Petroleum Institute,2010,34(5):101-109,171.
[224] 赵立新,蒋明虎.液液水力旋流器流场特性与分离特性研究(七)——操作参数对分离特性的影响[J].化工装备技术,2000(2):5-8. ZHAO Lixin,JIANG Minghu. Study on the flow field characteristics and separation characteristics of liquid-liquid hydrocyclones (7)——The influence of operating parameters on separation characteristics[J]. Chemical Equipment Technology,2000(2):5-8.
[225] SABBAGH R,LIPSETT M G,KOCH C R,et al. An experimental investigation on hydrocyclone underflow pumping[J]. Powder Technology,2017,305:99-108.

过滤-旋流耦合技术在非均相分离中的研究及应用

Research and Application of Filtering-swirl Coupling Technology in Heterogeneous Separation

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王艳, 何顺, 陈奕璋, 姜晨, 钱兆峰, 陈浩毅. 超声空化辅助金刚石线锯切割单晶硅机理分析与试验验证[J]. 机械工程学报, 2024, 60(9): 114-126.
[2]	魏荣, 徐默然, 李常平, 李树健, 李鹏南. 电火花辅助铣削钛合金多能场建模及调控优化研究[J]. 机械工程学报, 2024, 60(9): 393-409.
[3]	韩建超, 张孟非, 王斌, 国生辉, 贾燚, 王涛. 钛合金电致塑性本构方程及多物理场耦合分析[J]. 机械工程学报, 2024, 60(9): 421-433.
[4]	张行, 富宽, 陈铭浩, 李睿, 石新娜. 压差式多节串联管道机器人越障时动力学演化规律及减振分析[J]. 机械工程学报, 2024, 60(8): 348-359.
[5]	和东平, 王涛, 刘元铭, 徐慧东, 王君, 王志华. 板带轧机振动理论研究进展[J]. 机械工程学报, 2024, 60(7): 93-113.
[6]	商德勇, 黄欣怡, 黄云山, 张天佑. 基于Kane方程的Delta并联机器人刚柔耦合动力学研究[J]. 机械工程学报, 2024, 60(7): 124-133.
[7]	姜文涛, 刘晓明, 李培源, 陈海, 张煦松. 机械式真空快速切换开关机构多目标优化设计[J]. 机械工程学报, 2024, 60(6): 153-162.
[8]	陈清华, 杨云帆, 閤鑫, 凌亮, 王开云. 基于电磁力作用的地铁列车防滑控制研究[J]. 机械工程学报, 2024, 60(6): 334-341.
[9]	商德勇, 黄云山, 黄欣怡, 潘崭. 基于奇异摄动的刚柔耦合Delta机器人非线性混合控制[J]. 机械工程学报, 2024, 60(5): 95-106.
[10]	陈益丽, 柳军, 梁爽. 钻井液流变性对转盘钻井钻柱耦合振动抑制的参数影响研究[J]. 机械工程学报, 2024, 60(5): 183-195.
[11]	朱海燕, 黎洁, 肖乾, 陈道云. 轮轨激励对高速列车轴装制动盘热-机耦合疲劳分析[J]. 机械工程学报, 2024, 60(4): 409-419.
[12]	曾少昔, 赵春田, 李红梅. 铁磁材料漏磁信号对拉伸应力的响应研究[J]. 机械工程学报, 2024, 60(20): 68-76.
[13]	陆浩然, 邹梦珍, 李哲. 基于电化学-热耦合模型的长/短刀片型锂离子电池性能比较研究[J]. 机械工程学报, 2024, 60(20): 193-207.
[14]	唐新姿, 李可翔, 何文双, 陈睿, 彭锐涛. 多工况风电叶片颤振相关性分析与气弹优化[J]. 机械工程学报, 2024, 60(20): 300-314.
[15]	樊丁, 李德全, 侯英杰, 黄健康, 冯毅. GMAW潜弧焊电弧-熔池耦合行为数值分析[J]. 机械工程学报, 2024, 60(2): 159-167.