考虑应力偶计入区间及黏压效应的倾斜轴承非牛顿流体润滑特性研究

doi:10.3901/JME.2021.09.139

机械工程学报 ›› 2021, Vol. 57 ›› Issue (9): 139-146.doi: 10.3901/JME.2021.09.139

扫码分享

考虑应力偶计入区间及黏压效应的倾斜轴承非牛顿流体润滑特性研究

朱军超¹, 钱海俣¹, 郑良焱², 朱汉华²

1. 江苏科技大学能源与动力学院镇江 212000;
2. 武汉理工大学能源与动力工程学院武汉 430063

收稿日期:2020-05-09 修回日期:2020-12-15 出版日期:2021-05-05 发布日期:2021-06-15
作者简介:朱军超，男，1988年出生，博士，讲师。主要研究方向为轴承润滑及轴系振动。E-mail：zjc330@126.com
基金资助:
国家自然科学基金（51839005）和镇江市船舶动力设备性能重点实验室基金（SS2018006）资助项目。

Analysis of Misaligned Journal Bearing Lubrication Performance with Consideration of Couple Stress Lubricant Area and Viscosity-pressure Effect

ZHU Junchao¹, QIAN Haiyu¹, ZHENG Liangyan², ZHU Hanhua²

1. School of Energy and Power Engineering, Jiangsu University of Science and Technology, Zhenjiang 212000;
2. School of Energy and Power Engineering, Wuhan University of Technology, Wuhan 430063

Received:2020-05-09 Revised:2020-12-15 Online:2021-05-05 Published:2021-06-15

摘要/Abstract

摘要： 以滑动轴承为研究对象，考虑轴颈倾斜及润滑油黏压效应影响，建立轴承应力偶流体动力润滑模型，引入临界油膜厚度系数，探究应力偶流体对油膜厚度的敏感度，分析应力偶流体计入区域、应力偶系数、倾斜角及黏压效应对轴承润滑特性的影响。结果表明：随着应力偶系数的增加，润滑特性参数随油膜厚度的敏感度逐渐增加。较牛顿流体，考虑滑油应力偶效应时，轴承油膜压力显著增加，且随着应力偶计入区域的增加，轴承最大油膜压力逐渐增加，摩擦因数逐渐减小。在最小油膜厚度区域附近计入应力偶效应时，影响最为显著。轴颈发生倾斜时，倾斜作用将加剧应力偶效应，且随着应力偶系数的增加，倾斜对应力偶效应的影响愈加显著。黏压效应对应力偶流体轴承油膜压力有显著影响，但对于摩擦因数及端泄流量，其影响微弱。

关键词: 倾斜滑动轴承, 应力偶流体计入区间, 黏压效应, 润滑特性参数

Abstract: A misaligned journal bearing is taker as research object, and its lubrication model is built with consideration of couple stress lubricant area and viscosity-pressure effect. In order to explore the sensitivity of couple stress fluid to oil film thickness, the critical oil film thickness coefficient is introduced. Then the influence of couple stress lubricant calculation area, misaligned angle, viscosity-pressure effect and couple stress parameter on bearing lubrication characteristics are studied. The result shows that: the response sensitivity of lubrication performance on oil film thickness grows with the increase of couple stress parameter and it comes highest on the area of min oil film thickness. Comparing with the Newton lubricant, the bearing oil film pressure increases obviously when considering the effect of couple stress, and the bearing oil film pressure comes higher and friction coefficient comes lower when more couple stress areas were taken into consideration. The effect of lubricant couple stress increases when the journal is misaligned, and the effect grows with the increase of couple stress parameter. Viscosity-pressure effect takes an important role in bearing oil film pressure which lubricated couple stress lubricant, but its effect is relatively low on frictional coefficient and end leakage flow rate.

Key words: misaligned journal bearing, couple stress consideration area, viscosity-pressure effect, lubrication characteristics

中图分类号:

TH113

朱军超, 钱海俣, 郑良焱, 朱汉华. 考虑应力偶计入区间及黏压效应的倾斜轴承非牛顿流体润滑特性研究[J]. 机械工程学报, 2021, 57(9): 139-146.

ZHU Junchao, QIAN Haiyu, ZHENG Liangyan, ZHU Hanhua. Analysis of Misaligned Journal Bearing Lubrication Performance with Consideration of Couple Stress Lubricant Area and Viscosity-pressure Effect[J]. Journal of Mechanical Engineering, 2021, 57(9): 139-146.

参考文献

[1] BOUCHERIT H，LAHMAR M，BOU S B. Misalignment effects on steady-state and dynamic behaviour of compliant journal bearings lubricated with couple stress fluids[J]. Lubr. Sci.，2008，20：241-268.
[2] ZHU Junchao，ZHU Hanhua，FAN Shidong，2016. A study on the influence of oil film lubrication to the strength of engine connecting rod components[J]. Engineering Failure Analysis，2016，63：94-105.
[3] 王晓力，朱克勤. 基于应力偶流体模型的动载轴承润滑研究[J]. 清华大学学报，2001，41(8)：60-63. WANG Xiaoli，ZHU Keqin. Lubricating performance of dynamically loaded journal bearings based on couple stress fluid model[J]. Journal of Tsinghua University，2001，41(8)：60-63.
[4] 王晓力，朱克勤. 应力偶对滑动轴承热流体动力学特性影响[J]. 清华大学学报，2002，42(2)：239-242. WANG Xiaoli，ZHU Keqin. Effect of couple stress on the thermohydrodynamic performance of journal bearings[J]. Journal of Tsinghua University，2002，42(2)：239-242.
[5] 张俊岩，王晓力. 基于质量守恒边界条件的应力偶流体润滑动载轴承特性[J]. 机械工程学报，2010，46(15)：102-106. ZHANG Junyan，WANG Xiaoli. Performance of dynamically loaded journal bearing with couple stress fluids considering mass-conserving boundary condition[J]. Journal of Mechanical Engineering，2010，46(15)：102-106.
[6] 马艳艳. 应力偶流体润滑滑动轴承性能影响因素研究[J]. 机械科学与技术，2011，30(9)：1565-1568. MA Yanyan. Influential factors on the performance of journal bearings lubricated with couple stress fluids[J]. Mechanical Science and Technology for Aerospace Engineering，2011，30(9)：1565-1568.
[7] ZHANG Yongfang，WU Peng，GUO Bo，et al. Approximate solution of oil film load-carrying capacity of turbulent journal bearing with couple stress flow[J]. Chinese Journal of Mechanical Engineering，2015，28(1)：106-114.
[8] BHARATI M S， HIREMATH P S，BUJURKE N M. A novel numerical scheme for the analysis of effects of surface roughness on EHL line contact with couple stress as lubricant[J]. Sadhana，2018，43：1-12.
[9] JOON Y J，MICHAEL M K. On the characteristics of misaligned journal bearings[J]. Lubricants，2015，3：27-53.
[10] 孙军. 曲轴-轴承系统摩擦学、刚度和强度的耦合研究[D]. 合肥：合肥工业大学，2005. SUN Jun. Coupling research on tribology，stiffness and strength of crankshaft-bearing system[D]. Hefei：Hefei University of Technology，2005.
[11] LI Biao，SUN Jun，ZHU Shaoyu，et al. Thermohydrodynamic lubrication analysis of misaligned journal bearing considering the axial movement of journal[J]. Tribology International，2019，135：397-407.
[12] STOKES V K. Couple stresses in fluids[J]. The Physics of Fluids，1966，9：1709-1715.
[13] COSTA L，FILLON M，MIRANDA AS，et al. An experimental investigation of the effect of groove location and supply pressure on the THD performance of a steadily loaded journal bearing[J]. Journal of Triblogy，2000，122：227-232.
[14] 王晓力，朱克勤. 计入应力偶效应和空化效应的滑动轴承热流体动力润滑数值研究[J]. 工程力学，2002，19(5)：160-164. WANG Xiaoli，ZHU Keqin. A numerical study of the thermohydrodynamic performance of journal bearings considering the effects of couple stress and cavitation[J]. Engineering Mechanics，2002，19(5)：160-164.
[15] 温诗铸，黄平，田煜，等. 摩擦学原理[M]. 北京：清华大学出版社，2018. WEN Shizhu，HUANG Ping，TIAN Yu，et al. Principles of tribology [M]. Beijing：Tsinghua University Press，2018.
[16] SUN J，GUI C L. Hydrodynamic lubrication analysis of journal bearing considering misalignmentcaused by shaft deformation[J]. Tribology International，2004，37：841-848.
[17] ABDALLAH A E. Effects of misalignment on the performance of finite journal bearings lubricated with couple stress fluids[J]. Int. J. Computer Application in Technology，2004，21(3)：137-146.

考虑应力偶计入区间及黏压效应的倾斜轴承非牛顿流体润滑特性研究

Analysis of Misaligned Journal Bearing Lubrication Performance with Consideration of Couple Stress Lubricant Area and Viscosity-pressure Effect

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 1

编辑推荐

Metrics

本文评价